2004 Ford F-350 Sd

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.

IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.

WHEN GOING AROUND CURVES, HITTING SMALL BUMPS, OR STOPPING, THE FRONT END STARTS TO SHAKE VIOLENTLY. SLOWING DOWN OR STOPPING IS THE ONLY WAY TO STOP THE SHAKING. THE TRUCK HAS BEEN TAKEN TO SEVERAL REPAIR SHOPS WITH NO AVAIL. THEY CAN'T FIND ANYTHING WRONG. THIS PROBLEM IS VERY DANGEROUS. I'M GETTING SCARED TO DRIVE IT.

NHTSA ID

11004242

Incident

Jul 1, 2017

Mileage

125,000 mi

TL* THE CONTACT OWNS A 2004 FORD F-350 SD EQUIPPED WITH BF GOODRICH BAJA CHAMPION ALL TERRAIN (NA) TIRES, SIZE: FT285/75/R16 (NA). WHILE DRIVING 40 MPH, THERE WAS AN ABNORMALLY LOUD POPPING NOISE THAT CAME FROM THE LOWER PART OF THE VEHICLE. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER TO THE SHOULDER, WHERE IT WAS WITNESSED THAT A REFLECTOR HAD LODGED ITSELF INTO THE REAR DRIVER SIDE TIRE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIRE FAILED DUE TO IT BEING PUNCTURED AND WOULD NEED TO BE REPLACED. THE TIRE WAS REPLACED. THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 145,006 AND THE TIRE FAILURE MILEAGE WAS 60.

NHTSA ID

10838195

Incident

Feb 13, 2016

Mileage

145,006 mi

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

NHTSA ID

10762356

Incident

Sep 8, 2015

Mileage

155,061 mi

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

NHTSA ID

10762354

Incident

Sep 8, 2015

Mileage

155,061 mi

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

NHTSA ID

10762353

Incident

Sep 8, 2015

Mileage

155,061 mi

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

NHTSA ID

10762348

Incident

Sep 8, 2015

Mileage

155,061 mi

BOUGHT BFG COMMERCIAL T/A TIRES FROM COSTCO LAKE ELSINORE, CA ON 05-23-2015 I WENT BACK TO COSTCO WITH A HANDLING COMPLAINT AFTER A RECENT CAMPING TRIP FIRST TIME ON THESE TIRES. WITH MY 29 FOOT TRAVEL TRAILER MY TRUCK HANDLES VERY POORLY TIRE SIDE WALLS FEEL VERY SOFT MAKES HANDLING A SERIOUS SAFETY ISSUE. TRUCK FEELS LIKE ITS WANDERING AND WHEN TRYING TO STOP THE TRAILER THE TIRES FEEL AS IF THEY ARE TRYING TO COME OF THE RIMS. MY TRUCK IS A 2004 FORD F-350 SRW TRUCK MORE THAN CAPABLE OF TOWING THIS TRAILER. THE TRUCKS MILEAGE AT THE TIME OF INSTALL WAS 154601 CURRENT MILEAGE IS 155061 SO I HAVE PUT A TOTAL OF 460 MILES ON THESE TIRES. COSTCO WOULD ONLY REBALACE AND ROTATE TIRES WITHOUT ANY OF MY SAFTEY CONCERNS ADDRESSED.

NHTSA ID

10762347

Incident

Sep 8, 2015

Mileage

155,061 mi

WHILE DRIVING ON THE HIGHWAY AT AROUND 55MPH, THE TRUCK STOPPED RUNNING WITH NO PRIOR WARNING OR ANY PRIOR ISSUE. AFTER IT SHUT OFF THE TRUCK WOULD CRANK BUT NOT START. INCIDENT WAS VERY UNSAFE AS THE VEHICLE SHUT OFF AT HIGHWAY SPEEDS.

NHTSA ID

10732047

Incident

Jun 9, 2015

Mileage

181,500 mi

When performing any transmission fluid changes or topoffs involving MERCON SP, MERCON LV has replaced all versions of MERCON SP and can be used going forward. Mixing MERCON LV and MERCON SP in the same transmission is acceptable. After 30-Jun-2023, MERCON SP ATF will no longer be manufactured and will only be available until inventory depletes.

This SKU is a Transmission Line. The customer communication requested return of unsold inventory to inspect the connector. The transmission line connector may have an incorrect thread size, which will prevent it from being installed.

This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.

This SKU is a Spare Tire Hoist. Test results identified that the pull force parameter was not within specification, as a precautionary measure unsold inventory was requested to be returned for testing and containment. We don't have evidence that these test results have contributed to a product failure.

Some 2002-2008 F-Super Duty, F-150 and Mark LT vehicles may exhibit concern during or after programing the VSM. The programming may fail or vehicle symptoms such as inoperative door locks, dome lamps, door ajar indicators or auto lamps may occur after successful programing. To ensure the VSM is configured correctly, use the Integrated Diagnostic System (IDS) scan tool and select the blue ball and socket icon in the upper left corner. Select the utility knife in the bottom left corner. Select Update/Special Function and enter 53061 in the blue box then press the tick mark. The screen will go back to the system utilities page. Navigate to the toolbox tab and run the Programmable Module Installation (PMI) on the VSM. The procedure will prompt you to manually enter the as-built into the VSM. Obtain the as-built data from PTS > OASIS > As-Built.

This SKU is a front upper ball joint. The Customer communication requested return of unsold inventory to inspect for ball studs with excessive rotational friction in the ball joint assembly. Excessive friction in the ball joint assembly may cause a perceptible increase in steering effort.