2013 Ford F-350 Sd

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.

Cp4 pump failure resulting in stalled engine and loss of power brakes and power steering. Lifter failure resulting in loss of power and check engine light illuminating

NHTSA ID

11525000

Incident

Apr 21, 2023

WHEN MY TRUCK HITS A BUMP AT 40-60MPH, MY TRUCK BEGINS TO GO INTO A DEATH WOBBLE WHERE THE STEERING WHEEL AND TIRED SHAKE UNCONTROLLABLY UNTIL I STOP THE VEHICLE. I HAVE SPENT A TON OF MONEY TRYING TO REMEDY THE PROBLEM. I HAVE HAD MY TRUCK IN AND OUT OF THE DEALERSHIP TRYING TO FIX IT WITH NO RESOLVE. I HAVE A VIDEO TO SEND YOU BUT THIS WEBSITE ONLY ACCEPTS PHOTOS AND DOCUMENTS.

NHTSA ID

11316764

Incident

Jun 1, 2015

Mileage

25,000 mi

STILL HAVING THE "DEATH WOBBLE" ISSUE AFTER SPENDING $1K AT THE DEALERSHIP TO FIX THIS ISSUE. NOT EVEN 3000 MILES LATER IT IS HAPPENING AGAIN WORSE AND MORE FREQUENT THAN BEFORE. I WAS DRIVING ON THE HIGHWAY AT APPROX. 70 MPH AND AFTER HITTING A BRIDGE EXPANSION JOINT I NEARLY LOST CONTROL.

NHTSA ID

11210189

Incident

May 5, 2019

Mileage

142,000 mi

TL* THE CONTACT OWNS A 2013 FORD F-350 SD. THE CONTACT STATED THAT THE ELECTRONIC FUNCTION OF THE FRONT PASSENGER SIDE MIRROR WAS NOT WORKING PROPERLY WHEN IT WAS ADJUSTED USING THE CONTROL BUTTONS. THE DEALER (TOWNSEND SALES & SERVICE, 340 MAIN ST, TOWNSEND, MA 01469, (978) 597-8955) WAS NOTIFIED OF THE FAILURE NUMEROUS TIMES WHEN THE VEHICLE WAS TAKEN TO THE DEALER FOR SERVICING, BUT THEY FAILED TO DETERMINE THE CAUSE OF THE ELECTRONIC FAILURE. THE DEALER INDICATED THAT THEY SERVICED THE MIRROR UNDER A WARRANTY, BUT PROVIDED NO SPECIFIC ANALYSIS OF WHAT WAS DIAGNOSED OR REPAIRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND THEY INDICATED THAT THE VEHICLE WAS OUT OF WARRANTY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND SUGGESTED THAT THE CONTACT TAKE THE VEHICLE BACK TO THE DEALER FOR SERVICING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 27,000.

NHTSA ID

11110779

Incident

Jun 1, 2018

Mileage

27,000 mi

TRAVELING, APPROX. 70 MPH ON I-20 JUST WEST OF CAMDEN S.C. FELT A VIBRATION IN THE STEERING OF THE TRUCK. HEARD A LOUD EXPLOSION FOLLOWED BY THE DRIVER REAR SUDDENLY DROP, LOOKING IN THE SIDE MIRROR, SAW THE TIRE COMING APART. PULLED TO THE CENTER MEDIAN, THE SIDE, AND BED HEAVILY DAMAGED. TIRE HAD COME APART LIKE A RETREAD, WHICH IT WASN'T. BFGOODRICH LT305/65/R17, DOT BE09 MANUFACTURE 1312

NHTSA ID

10983673

Incident

May 1, 2017

Mileage

21,320 mi

TIRE SEPARATION. 4 OF 5 ORIGINAL EQUIPMENT MICHELIN LTX M'S2 225/75 R16 TIRES HAVE FAILED.

NHTSA ID

10978654

Incident

Apr 15, 2017

Mileage

6,100 mi

NOTICED ODD SMELL AT APPROX 50K MILES. THOUGHT IT WAS BURNED OIL. SERVICED AT FORD DEALER - BRAKE FLUID LEAKING FROM REAR BRAKE CALIPER FAILURE. DEALER REPLACED BRAKE CALIPER AND PADS. AFTER SERVICING, BRAKE FLUID SMELL CONTINUED. SERVICED AGAIN AT APPROX 56K MILES - BRAKE LINE LEAKING.

NHTSA ID

10840421

Incident

Mar 7, 2016

Mileage

54,000 mi

SUNROOF EXPLODED SITTING STILL SHOWERING EVERYONE WITH GLASS, SOME GLASS GOT IN OCCUPANT FACE AND EYES

NHTSA ID

10816612

Incident

Dec 26, 2015

Mileage

27,500 mi

Some 2013-2016 Super Duty vehicles equipped with a 6.7L diesel engine and 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may not pass a state smog test due to the exhaust gas system (EGS) monitor that will not run after completing the Exhaust Gas Sensor drive cycle located within Section 2 of the Powertrain Control/Emissions Diagnostics (PC/ED) Manual > Drive Cycles. This may be due to the vehicles diesel oxidation catalyst (DOC) age counter being under the 120-minute requirement. Engineering is investigating this issue and working on a solution.

Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. Unlike the integrated wired keypad, the accessory wireless keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool or from the label printed on the body control module (BCM). The Factory Keyless Entry Code application within the diagnostic scan tool will not provide an applicable master code for the accessory wireless keypad. If the wallet card for an accessory keypad is not available, the "Wireless RF Keypad Diagnosis Guide" can be referenced and provides direction on how to retrieve the master code. This guide is located under the Workshop Manual tab > Accessories > Installation > Wireless RF Keypad Diagnosis Guide > PPT C > Step C2.<br /><br /> Note: The only available keypad for some vehicles from the assembly plant is the accessory wireless keyless entry keypad. The integrated wired keypad cannot be installed on vehicles not equipped from the factory with a wired keyless entry k

Certain 2011-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine - Emission Control Information Label Update for Qualified Vehicles

While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions. While performing a transmission repair on some 2012-2024 Ford and Lincoln vehicles, a transmission seal kit may be on backorder due to supply chain interruptions.

All accessory stick-on keyless entry keypads come with a wallet card containing the master code. If the accessory keypad was factory installed, this card will be placed in the glove box and should be handed to the vehicles owner during initial delivery. Unlike the integrated (wired) factory keypad, the accessory keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool. If the wallet card for an accessory keypad is lost, follow these steps to recover the code. Dealer Key Code access is granted through the Dealer Program Enrollment System (DPES); dealership management can authorize users. The authorized user must go to FMCDealer.com > Parts and Service > Parts Product Line Information > Keys/Entry Devices > Aftermarket Keyless Entry Keypad Code Access. Follow the instructions on the screen to obtain the master code for the accessory keypad.

2024 F-Super Duty vehicles are equipped with XL-22 (WSS-M2C184-A1) high temperature power steering fluid that looks like clear hydraulic fluid. This fluid is an improvement in high temperature and thermal oxidative stability compared to Mercon LV. This power steering fluid is also compatible and highly recommended to use when filling or topping off power steering systems of all 2012-2023 F-Super Duty vehicles originally equipped with Mercon LV.