2001 Jeep Cherokee

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

The contact owns a 2001 Jeep Cherokee. The contact stated while driving 10 mph, the vehicle lost motive power without warning and there was smoke coming from the engine. The vehicle was towed to an independent mechanic and diagnosed that the top cylinder was faulty. The vehicle was then towed to a dealer, but the dealer informed the contact that they did not repair vehicles older than 2006 and would only order a part to cover the manifold. The vehicle was not diagnosed nor repaired. The Vin was included in NHTSA Campaign Number: 02V104000 (Fuel System, Gasoline). The manufacturer was made aware of the failure and a case was opened. The manufacturer informed the contact to take the vehicle to a dealer for diagnosis. The failure mileage was 145,333.

NHTSA ID

11424645

Incident

Jul 6, 2021

Mileage

145,333 mi

THE STOCK SEAT BELTS LOCATED IN THE REAR SEAT OF THE VEHICLE DO NOT LOCK IN ORDER TO PROPERLY AND SAFELY INSTALL CHILD SAFETY SEATS. THIS IS NOT A ONE TIME THING AS THEY WILL NOT SECURE AFTER BEING FULLY EXTENDED. I HAVE ALREADY CONTACTED A DEALER AFTER FINDING AN OLD RECALL BUT WAS TOLD THEY WOULD NOT FIX AS THEY DIDN'T KNOW WHAT I WAS SPEAKING OF.

NHTSA ID

11310104

Incident

Feb 19, 2020

CPSC: PURCHASED A SET OF THE ABOVE PISTONS TO REPLACE PISTONS ON A 2001 JEEP CHEROKEE SPORT. THE FIRST SET FAILED ON THE SECOND OPENING CAUSING MINOR VEHICLE DAMAGE TO THE LIFT GATE. THE LOCKING CLIP DID NOT HAVE SUFFICIENT STRENGTH TO HOLD ONTO THE PROVIDED BRACKET. *DT *JS

NHTSA ID

11104408

Incident

Jun 12, 2018

GAS TANK IS DANGEROUS, JUST LIKE RECALL IVE SEEN. COVER HAS RUSTED AWAY SKID PLATE GONE EXPOSING GAS TANK

NHTSA ID

11075780

Incident

Feb 27, 2018

Mileage

150,000 mi

AS WITH MANY OTHER JEEP OWNERS WITH THE 4.0 ENGINE (HUNDREDS THAT I HAVE SEEN) MY 2001 JEEP CHEROKEE'S CYLINDER HEAD CRACKED. MINE WAS AT 117K MILES, AND THE AVERAGE MILEAGE FOR FAILURE SEEMS TO BE 100K - 120K MILES. THIS IS A DEFINITE DESIGN FLAW. MY JEEP WAS WELL MAINTAINED AND SHOULD NOT HAVE HAD A CRACKED CYLINDER HEAD. I ASK NHTSA TO CONTACT CURRENT OWNERS OF JEEP 4.0 ENGINES TO REALLY SEE HOW OFTEN THIS FAULT OCCURS. CHRYSLER SEEMS TO TAKE NO RESPONSIBILITY FOR THIS, WHICH IS WHY I AM ASKING THE NHTSA TO INVESTIGATE.

NHTSA ID

11023480

Incident

Jan 5, 2017

Mileage

117,000 mi

IN THE 2000 AND 2001 CHEROKEES WITH THE 4.0 ENGINE HEAD CASTING 0331 CHRYSLER KNEW ABOUT THE CYLINDER HEADS CRACKING. IN 2002 THEY CONTRACTED WITH TUPY MANUFACTURING IN BRAZIL TO REMAKE THE HEAD CASTING THAT RAN UNTIL THE 4.0 WAS STOPPED BEING USED BY THEM. MINE HAS SINCE CRACKED AND CHRYSLER SAYS THAT NO FACTORY RECALL WAS DONE AND SUCH I'M STUCK WITH A CRACKED HEAD THAT THEY KNEW WAS FAULTY.

NHTSA ID

10940248

Incident

Dec 16, 2016

Mileage

146,000 mi

TAKATA RECALL-- I HAD AN ACCIDENT JANUARY 7, 2016, I HIT A POLE. THE AIRBAGS DID NOT DEPLOY. I DID A SEARCH AND I FOUND OUT THERE WAS A RECALL ON THIS JEEP. I ONLY HAD LIABILITY INSURANCE. I GOT IN TOUCH WITH THE COMPANY THEY HAD THE CAR TOWED TO A DEALERSHIP AND SUPPOSEDLY HAD IT CHECKED OUT BUT I DON'T BELIEVE IT. I MYSELF AND MY GIRLFRIEND WAS INJURED AND UNDER DOCTORS CARE. MY CAR IS TORE UP IN THE FRONT. WHY? THOSE AIRBAGS DID NOT DEPLOY. THEY COULD NOT TELL ME. I WAS TRAVELING ON RTE 49 EAST.

NHTSA ID

10862349

Incident

Jan 7, 2016

Mileage

137 mi

2001 JEEP CHEROKEE. CONSUMER WRITES IN REGARDS TO SEVERAL VEHICLE RECALLS AND AIRBAG MALFUNCTION DURING AN ACCIDENT. *SMD

NHTSA ID

10851617

Incident

Mar 1, 2016

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number. The "AB" NIC level will not program to these platforms. For all other platforms, if the "AB" NIC level will not program to the vehicle, use the "AC" NIC level part and submit a part warranty.

Disinfectant Solution Recommended for COVID-19

Charging System, Battery Diagnostic Tools and Warranty This information only bulletin discusses using the correct test equipment for testing batteries and charging systems, and also warranty reimbursement when battery replacements are necessary.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.

Use of Salvage/Recycled Parts This bulletin involves discussing FCA US LLC position with regard to collision repair industry awareness regarding the use of recycled or salvage parts.