RoadVitals

2010 Keystone Fuzion

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
12
Latest Jul 31, 2015
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
6
Latest Nov 22, 2017
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1

Overview

Our database contains 12 NHTSA owner-reported complaints for the 2010 Keystone Fuzion, most frequently naming the other / unspecified, electrical and body & structure categories. 6 safety recalls have been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Other / unspecified533.3%
  • Electrical426.7%
  • Body & structure213.3%
  • Tires & wheels213.3%
  • Fuel system16.7%
  • Interior & seats16.7%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

6 campaigns cover this model year

View all 6

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
17V755000

EQUIPMENT

Nov 22, 2017
1,205,997 units potentially affected
The defect: Keystone RV Company (Keystone) is recalling various 2003-2018 Crossroads, Dutchmen, and Keystone recreational trailers equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V755-5127.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
The risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
The remedy: Keystone will notify owners and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Keystone customer service at 1-574-535-2100, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Keystone's number for this recall is 17-307.
Keystone RV CompanyManufacturer number 17-307View on NHTSA.gov
11V577000

ELECTRICAL SYSTEM

Dec 8, 2011
6,101 units potentially affected
The defect: KEYSTONE HAS REVISED THEIR REMEDY PROCESS AND IS AGAIN RECALLING CERTAIN 2009-2011 VEHICLES WITH THE “GENERATOR READY” OPTION, OR WITH STANDARD GENERATOR. SEE THE LIST ABOVE FOR THE AFFECTED MODELS. SOME IOTA ITS-50R TRANSFER SWITCHES ARE EXPERIENCING FAILURES WHEN EXPOSED TO HIGH ELECTRICAL LOADS. THE FAILURE IS CAUSING CONNECTIONS AND WIRING IN THE TRANSFER SWITCH TO DEGRADE AND OVER HEAT.
The risk: CONTINUED USE OF THE VEHICLE WITHOUT REPLACING THE TRANSFER SWITCH MAY DAMAGE OTHER APPLIANCES, INCREASE THE RISK OF A FIRE, PERSONAL INJURY, AND PROPERTY DAMAGE.
The remedy: KEYSTONE WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE TRANSFER SWITCH, FREE OF CHARGE. THE REMEDY FOR THE PREVIOUS RECALL (10V-594) WAS TO INSPECT AND TIGHTEN THE SWITCH CONNECTIONS. THE SAFETY RECALL BEGAN ON FEBRUARY 24, 2012. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
KEYSTONE RV COMPANYView on NHTSA.gov
10V594000

ELECTRICAL SYSTEM

Nov 23, 2010
6,297 units potentially affected
The defect: KEYSTONE IS RECALLING CERTAIN FIFTH WHEEL TRAILERS WITH A GENERATOR READY OPTION. IF THE TRANSFER SWITCH IS NOT INSTALLED TO THE PROPER SPECIFICATIONS, THE ELEVATED ELECTRICAL LOADS ASSOCIATED WITH THE RECREATIONAL VEHICLE USE IN HIGHER AMBIENT TEMPERATURES MAY CAUSE OVERHEATING OF THE LUGS AND DEGRADING OF THE ELECTRICAL CONNECTIONS.
The risk: OVERHEATING OF THE CONNECTIONS COULD RESULT IN A FIRE.
The remedy: DEALERS WILL INSPECT AND REPLACE THE TRANSFER SWITCH IF NECESSARY FREE OF CHARGE. THE SAFETY WAS SUPERCEDED BY CAMPAIGN 11V-577. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
KEYSTONE RV COMPANYManufacturer number 10-153View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 12
Filed Jul 31, 2015

THE FRESH WATER TANK IN THE REAR OF THE TRAILER FELL DOWN AND WAS SITTING RIGHT ON THE REAR AXEL. WE OPENED UP THE BOTTOM COVER OF THE TRAILER AND NOTICED THAT THE BARS USED TO SUPPORT THE TANK WERE ALL BENT AND A FEW OF THEM HAD POPPED OFF FROM THE FRAME. WE WERE ABLE TO JACK UP THE TANK AND REPAIR THE DAMAGE BY OURSELVES BECAUSE WE WERE OUT OF TOWN AND THE DEALERSHIP WOULD TAKE MONTHS TO FIX THIS AND THEN CHARGE US A HEFTY AMOUNT TO FIX IT. WE REPAIRED IT OURSELVES FOR BY REPLACING THE FLIMSY METAL BARS WITH MULTIPLE UNI-STRUT BARS TO SUPPORT THE WATER TANK. UPDATED 09/15/15*LJ *CN

NHTSA ID
10745342
Incident
Jul 21, 2015
Electrical
Filed Apr 6, 2014

2010 KEYSTONE FUZION II 5TH WHEEL UNIT. HAD TRANSFER SWITCH REPAIRED UNDER RECALL. HAD SEVERAL ITEMS REPAIRED, I.E. LIGHT FIXTURES, REAR RAMP WIRING, HOLDING TANK VALVE REPLACEMENTS AND REPAIRS, TIRE FAILURES. ISSUE NOW IS A WARNING LIGHT IN THE MAIN FUSE PANEL INDICATING A BLOWN FUSE. UPON CONTACTING MANUFACTURER, THE CUSTOMER SERVICE REP INDICATES THAT THERE IS NO TYPE OF STANDARD WIRING, PIPING OR OTHER DIAGRAMS TO TROUBLESHOOT ANY OF THESE SYSTEMS, ALTHOUGH A WARNING LIGHT WOULD MEAN A SHORT IN A WIRING SYSTEM. THE COST OF TAKING UNIT TO DEALER FOR REPAIRS IS BORN BY THE OWNER. DEALERS, ALL OF THEM, HAVE THE ATTITUDE OF "IF YOU DIDN'T BUY IT HERE, I DON'T WANT YOUR PROBLEMS." THEY COME UP WITH ANY EXCUSE TO NOT SERVICE THE UNIT PROPERLY, UNLESS OF COURSE YOU ARE PAYING THEIR REGULAR SHOP RATE, IF THEY WANT TO GET YOU IN. EXTENDED WARRANTIES ARE HONORED BY SOME AND NOT OTHERS, ALTHOUGH SOLD BY ALL DEALERS. *TR

NHTSA ID
10577756
Incident
Jul 2, 2011
Mileage
2,000 mi
Other / unspecified
Filed Jul 29, 2013

THE REAR RIGHT SIDE OF THE FRESH WATER TANK FELL DOWN WHILE TRAVELING, AND BEGAN DRAGGING ON THE ROAD. THE METAL U-CHANNEL SUPPORTS UNDER THE TANK BENT DOWN, AND BEGUN BREAKING THE TAP SCREWS ON EACH END, OR PULLING THEM THROUGH THE FRAME. OF THE 5 SUPPORTS UNDER THE TANK, TWO PULLED LOOSE FROM BOTH ENDS, TWO PULLED LOOSE ON ONE END, AND ONLY ONE, THE LEFT STRAP NEXT TO THE PLUMBING CONNECTIONS, WAS STILL ATTACHED ON BOTH ENDS. THE LOOSE SUPPORTS WERE PINNED BETWEEN THE TANK AND THE BOTTOM COVER, AND ONE OF THE SUPPORTS WAS GROUND DOWN BY THE PAVEMENT, WHICH SAVED DAMAGE TO THE TANK, WHICH WAS NEARLY FULL, 80 GALLON CAPACITY. THE FRONT CROSS ANGLE BAR, USED TO HOLD THE TANK IN PLACE AGAINST THE REAR FLOOR BEAM, WAS HELD IN PLACE WITH ONE SCREW ON EACH SIDE, INSTEAD OF TWO PER SIDE, WHICH ALLOWED THE BAR TO TIP DOWN, DROPPING THE TANK AS THE U-STRAP UNDER THE TANK BOWED DOWN. I WAS ABLE TO JACK UP THE TANK, AND PLACE A LARGE VEHICLE TIE DOWN STRAP UNDER THE TANK, RAISING IT TO TRAVEL HOME. I HAVE ALREADY REPAIRED THE DAMAGE, WHICH I TOOK PICTURES OF, AS I NEEDED THE CAMPER, NOT HAVE IT SIT ON THE DEALERS LOT ONCE AGAIN. I USED 1.5 INCH BOX TUBES, .125 THICK, WITH GRADE 5 BOLTS ON EACH END, TO SUPPORT THE TANK. UPDATED 9/24/13 *CN *TR

NHTSA ID
10532282
Incident
May 26, 2013
Mileage
3,000 mi
Electrical
Filed Jan 21, 2013
Fire reported

WE BOUGHT OUR 2010 KEYSTONE FUZION RV AROUND JUNE/JULY 2010. THE DEALER (CAMPING WORLD, S.C.) TOLD US THAT THE RV WAS A BRING-BACK, NEVER EVEN USED (WHICH, LOOKING BACK ON IT, MAKES ME WONDER IF THERE WERE PROBLEMS WITH THE UNIT FROM THE START). IN AUGUST 2010, WE TOOK IT ON A TRIP TO VIRGINIA. WE PLUGGED IN THE 50 AMP SERVICE AND ABOUT AN HOUR AFTER, THE UNIT CAUGHT FIRE IN THE STORAGE COMPARTMENT. THANKFULLY, MY HUSBAND WAS THERE WHEN IT HAPPENED AND WAS ABLE TO CONTAIN THE DAMAGE. WE IMMEDIATELY CONTACTED KEYSTONE RV, WHO HAD NO INTEREST WHATSOEVER IN WHAT HAPPENED. IT TOOK MONTHS BEFORE A DEALERSHIP IN PA FINALLY MADE THE REPAIRS,' REPLACING A BAD TRANSFER SWITCH. THIS PAST SUMMER (JUNE 2012) WE AGAIN TOOK THE UNIT TO S.C. FOR VACATION. WE SMELLED ELECTRICAL FIRE IN THE UNIT AND AGAIN, THANKFULLY, MY HUSBAND FOUND THE FIRE BEFORE ANY DAMAGE OCCURRED. WE AGAIN CALLED KEYSTONE RV, WHO DRUG THEIR FEET IN OFFERING ANY TYPE OF ASSISTANCE. THIS TIME, WE WERE ONLY A MILE OR SO FROM WHERE WE ORIGINALLY PURCHASED THE UNIT (CAMPING WORLD). AFTER MULTIPLE PHONE CALLS AND ARGUMENTS WITH KEYSTONE AND CAMPING WORLD, A TECH CAME TO OUR CAMPSITE AND FOUND THAT KEYSTONE RV HAD REPLACED THE ORIGINAL FAULTY TRANSFER SWITCH WITH THE SAME FAULTY TRANSFER SWITCH. THIS WAS TWICE THAT OUR FAMILY COULD HAVE SUFFERED INJURY OR DEATH AS A RESULT OF THEIR MISTAKE. WE HAVE NOT USED THE UNIT SINCE AND I AM HONESTLY SCARED TO USE IT. *TR

NHTSA ID
10493692
Incident
Aug 7, 2010
Electrical
Filed Jan 4, 2013

I HAVE RECEIVED A RECALL NOTICE FOR A DEFAULT IN A IOTA ITS-50R TRANSFER SWITCH. THESE SWITCHES ARE EXPERIENCING HEAT RELATED FAILURES. WARNING CONTINUED USE WITHOUT REPLACING INCREASES RISK OF FIRE, PERSONAL INJURY AND PROPERTY DAMAGE. I HAVE CONTACTED THE MANUFACTURER FOR REPAIR. I INFORMED THEM THAT THE UNIT IS PERMANENTLY SET AND NOT ABLE TO BE TAKEN TO A AUTHORIZED DEALER. I WAS INFORMED THAT THEY WOULD NOT PROVIDE A MOBILE SERVICE TO DO THE REPAIR. I DO NOT KNOW IF YOUR ORGANIZATION CAN BE OF ANY HELP IN PERSUADING THEM TO CHANGE THEIR POSITION IN PROVIDING A MOBILE SERVICE TO DO REPAIR. I WOULD GREATLY APPRECIATE ANY ASSISTANCE THAT YOU CAN PROVIDE. ALTHOUGH MY MAILING ADDRESS IS IN FLORIDA THE VEHICLE IS IN CORTEZ COLORADO. *TR

NHTSA ID
10491439
Incident
Nov 20, 2011
Other / unspecifiedTires & wheels
Filed Oct 6, 2012

THIS IS CONCERNING TIRES BEING USED ON THE KEYSTONE FUZION. THE BRAND OF TIRE IS CARLISLE AND THE TIRE THAT I AM HAVING PROBLEMS WITH IS THE ULTRA CRT RADIAL TRAIL, SIZE ST235/80R16. I HAD ONE TIRE SHOW SEVERE SIGNS OF SIDE WALL AND TREAD WALL SEPARATION SO IT WAS REPLACED. DURING A SHORT TRIP, I HAD A BLOW OUT ON ANOTHER TIRE. I HAVE SINCE HAD IT REPLACED AS WELL, AND I AM ALSO WORKING ON REPLACING THE REST. A SHORT INTERNET SEARCH ON THIS TIRE SHOWS NUMEROUS COMPLAINTS WITH BLOW OUTS. NOT ONLY CAN THIS CAUSE LOSS OF CONTROL, BUT THIS IS A DANGER TO OTHER MOTORISTS WITH FLYING DEBRIS AFTER A BLOW OUT. ESPECIALLY TO ANY MOTORCYCLISTS, PEDAL CYCLISTS, OR PEDESTRIANS. *TR

NHTSA ID
10478863
Incident
Sep 22, 2012
ElectricalFuel systemOther / unspecified
Filed Jul 23, 2012

2010 KEYSTONE FUZION TOY HAULER. CONSUMER STATES PROBLEMS WITH CAMPER AND RECALL CONCERNING OVERHEATING OF LUGS AND DEGRADING OF THE ELECTRICAL CONNECTIONS *TGW THE CONSUMER STATED THE GENERATOR, SWITCH, WIRES, LIGHTS SCREEN DOOR, FUSES AND FUEL PUMP WERE REPLACED.

NHTSA ID
10467325
Incident
Jul 2, 2012
Other / unspecified
Filed Apr 26, 2011

TL* THE CONTACT OWNS A 2010 KEYSTONE FUZION FIFTH WHEEL CAMPER RV. THE CONTACT STATED THAT THE MIDDLE RESTROOM TOILET FLUSHED INTO THE GRAY TANK OF THE RV, WHICH WAS USED FOR NON-SEWAGE WATER DUMPING. THE CONTACT STATED THAT THE RESTROOM TOILET SHOULD HAVE FLUSHED INTO THE BLACK WATER TANK FOR SEWAGE PURPOSES. THE MANUFACTURER WAS CONTACTED ABOUT THE PROBLEM AND THE CONTACT WAS TOLD THAT THE VEHICLE WAS MADE TO PERFORM IN SUCH A MANNER. DUE TO THE SIZE ON THE GRAY WATER TANK, THE FAILURE WAS CAUSING THE TANK TO FILL UP QUICKLY AND WHEN DUMPED, IT WOULD EMIT RAW SEWAGE ONTO THE GROUND WHILE TRAVELING. THE FAILURE MILEAGE WAS 3,000.

NHTSA ID
10397521
Incident
Jun 16, 2010
Mileage
3,000 mi

Compare model years

Complaint and recall counts across every year of this model

Keystone Fuzion by model year
YearComplaintsRecallsInvestigationsIssue Index
2026010—
2025040—
2024010—
2023230—
2022250—
2021340—
2020250—
2019140—
2018140—
2017330—
2016140—
2015230—
2014320—
2013220—
2012110—
2011270—
2010Viewing1260—
2009250—
2008440—
2007040—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.