2025 Toyota Highlander

I was backing up the vechial accelerated the steering wheel was turning rapid & a grinding noise causing me too hit another vechial about a month before my husband was driving & the vechial accelerated going toward also we had had some issues with back camera not doing a warning signal with a object behind vechial when the accident happened my vechial has braking system that stops you if something is behind you this time it didn’t I called the dealership when accident happed which was May 21 2026 & reported it they said they had accelerations before & advised me to call Toyota engadgment which I did they did a diagnostic test June 5 & to this day I’ve never heard back from them

NHTSA ID

11753999

Incident

May 21, 2026

[XXX] was turning left onto [XXX] from [XXX]. Two lanes turn left. She was in the inside lane. The traffic light was red, and when it turned green, she started to turn. Partway through the turn, the steering became unresponsive. She couldn't get it to turn left, and she could not complete the turn, and crashed into the pole that holds the traffic signal. She traveled less than 100 ft total from the light to the pole. The accident was at 1:30 PM on a dry and clear day. The car has 8087 miles on it. There were no observed indications of warning lights and no symptoms of a problem. The vehicle was towed to a salvage lot, the Insurance company inspected it and declared it a total loss. All the airbags went off. I mentioned to the adjuster that there was a mechanical problem, and he said they would not investigate that. [XXX] suffered a broken rib on her left side and has some serious cuts from the airbag below the dash, and of course, the seatbelt soreness. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11750944

Incident

Jul 4, 2026

The contact owns a 2025 Toyota Highlander. The contact stated that while she and her husband were driving at 60 MPH, she heard a loud explosion noise from above her head and felt air whipping on top of her head. The contact stated that the sunroof exploded; however, the sunroof shield prevented the glass from entering the vehicle. The vehicle was steered to the side of the road and inspected, but the contact did not find anything wrong at that time. The vehicle was taken to a dealer where it was diagnosed that a rock may have hit the sunroof. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 8,498.

NHTSA ID

11741757

Incident

Jun 2, 2026

Mileage

8,498 mi

The speedometer registers speed up to 7mph over actual speed for the first 15 miles then returns to matching GPS speed. Reported to Toyota, dealer said they have seen this before but not identified a fix as of today

NHTSA ID

11740832

Incident

Jan 6, 2026

The contact owns a 2025 Toyota Highlander. The contact stated while driving at an undisclosed speed, there was an abnormally strong odor entering the cabin of the vehicle through the vents. The windows were rolled down due to the obnoxious odor. The vehicle was taken to the dealer and the contact was informed that the vehicle was tested for leaks in the exhaust; however, no leaks were found. The contact was informed that the fumes were possibly from burning wires or a new vehicle odor because the vehicle was a brand-new vehicle. In addition, the contact was offered the option to trade the vehicle in for a new vehicle. The contact stated that the odor was extremely strong and foul, and the odor stuck to clothing and the contact’s skin. In addition, the contact described the odor as an old lawnmower or snow blowing odor. The contact was advised by the state Attorney General Office of Illinois to contact NHTSA Hotline to report the failure. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 100. The VIN was not available.

NHTSA ID

11712542

Incident

Apr 8, 2025

Mileage

100 mi

I am reporting a safety defect in the 2025 Toyota Highlander Hybrid Nightshade involving the multifunction turn signal switch. The interior trim adhesive on the steering column has experienced a chemical breakdown (adhesive migration), causing the turn signal stalk to become stiff and bind. This obstruction makes it difficult to engage the turn signal and occasionally prevents the signal from "auto-canceling" after a turn. The dealership has acknowledged the adhesive failure by authorizing the replacement of the steering column covers but refuses to replace the contaminated turn signal switch. Operating a vehicle with a binding turn signal switch is a direct safety hazard, as it compromises the driver's ability to communicate intent to other motorists. Additionally, the dashboard material is experiencing systemic delamination and producing a white crystalline powder (crystallized adhesive). I am requesting an investigation into the heat-resistance standards of the interior bonding agents used in the 2025 Nightshade trim, as these materials are failing and compromising safety-critical electronic controls. Thank XXX XXX

NHTSA ID

11711474

Incident

Jan 16, 2026

Black Toyota Highlander Hybrid AWD 2025 ~15000 miles What component or system failed or malfunctioned, and is it available for inspection upon request? Without any warning, the braking action is delayed. It is a momentary loss and happens occasionally at light braking application, nowhere near hard enough to lock the wheels up The vehicle is available for inspection upon request How was your safety or the safety of others put at risk? If I were been closer to another vehicle/pedestrian/obstacle, an accident could happen Has the problem been reproduced or confirmed by a dealer or independent service center? No, yet, I will book an appointment to allow the dealer to verify the issue Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? NO Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? NO General: I have been driving the Highlander for a little bit more than a year, and this issue has happened at least 5 times, twice (2) this week

NHTSA ID

11707018

Incident

Dec 24, 2025

While waiting for a traffic light to change, I pressed the pedal to accelerate, and the car would not move. Like my pedal was dead. I have experienced this issue three times. I have also experienced bucking or jerking issues.

NHTSA ID

11690033

Incident

Sep 19, 2025

Some 2020 – 2026 model year Highlander and Highlander Hybrid vehicles may exhibit a water leak from the roof rack attachment clips. This may be caused by the sealant in the roof channel obstructing the proper seating position for the clip gasket.

Some 2005 – 2026 Toyota vehicles that have undergone water intrusion may exhibit a condition in which a musty odor is present. Follow the procedures in this bulletin to remediate the odor and address this condition. The purpose of this Service Bulletin is to provide general guidelines and procedures for odor remediation. This Service Bulletin provides a guide on how to prepare and treat the interior of the vehicle for odor remediation. Refer to the applicable model and model year Repair Manual and the EPA (Environmental Protection Agency) website for the most up-to-date safety and precautionary guidelines.

A new head unit software update is available for 2022 – 2025 model year Tundra, and Tundra Hybrid; 2023 – 2025 model year Corolla Cross, Corolla Cross Hybrid, Highlander, Highlander Hybrid, Mirai, and Sequoia Hybrid vehicles equipped with Toyota Multimedia versions earlier than version 2230.

The air conditioning dye injection tool kit has been developed to aid in identifying the location of air conditioning refrigerant leaks. The procedures outlined in this Service Bulletin aid in locating, inspecting, and repairing refrigerant leaks.

To assist with the early detection and early resolution of audio related concerns you may be asked to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by FTS and/or FPE.

To assist with the early detection and early resolution of audio related concerns you may be asked to recover MMR data from the head unit. The following steps are instructions on how to retrieve the data from the system and are only to be used when requested by FTS and/or FPE.