RoadVitals

2025 Chevrolet Corvette

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
10
Latest Apr 14, 2026
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest Apr 2, 2026
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1
1 injuries, 0 deaths reported

Overview

Our database contains 10 NHTSA owner-reported complaints for the 2025 Chevrolet Corvette, most frequently naming the interior & seats, fuel system and driver assistance categories. 3 safety recalls have been issued covering this model year; and 301 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Interior & seats218.2%
  • Fuel system218.2%
  • Driver assistance19.1%
  • Engine19.1%
  • Other / unspecified19.1%
  • Powertrain (other)19.1%
  • Body & structure19.1%
  • Visibility19.1%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
26V213000

EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE; EXTERIOR LIGHTING:TURN SIGNAL

Apr 2, 2026
32,988 units potentially affected
The defect: General Motors, LLC (GM) is recalling certain 2026 Chevrolet Corvette ZR1X Coupe, Corvette ZR1X Convertible, Corvette Coupe E-Ray, Corvette Convertible E-Ray, Corvette Convertible, Corvette Coupe, 2025 Corvette E-Ray Coupe, Corvette E-Ray Convertible, Corvette Convertible, and Corvette Coupe vehicles. A software error may prevent detection of a rear turn signal light failure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
The risk: The driver may be unaware that the turn signal is not working, increasing the risk of a crash.
The remedy: The lighting control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters are scheduled to be mailed May 18, 2026. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252541250. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov April 2, 2025.
General Motors, LLCManufacturer number N252541250View on NHTSA.gov
25V536000

FUEL SYSTEM, GASOLINE

Aug 21, 2025
23,656 units potentially affected
The defect: General Motors, LLC (GM) is recalling certain 2023–2026 Chevrolet Corvette vehicles equipped with a left-side radiator/fan combination. Excess fuel may spill into the vehicle fuel-filler pocket during refueling and leak onto an ignition source.
The risk: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
The remedy: Dealers will install a shield to divert spilled fuel, free of charge. Owner notification letters were mailed November 14, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252514930.
General Motors, LLCManufacturer number N252514930View on NHTSA.gov
24V418000

SEAT BELTS:FRONT:RETRACTOR

Jun 6, 2024
13,464 units potentially affected
The defect: General Motors, LLC (GM) is recalling certain 2024-2025 Chevrolet Corvette vehicles. The driver and/or passenger seat belt retractors may lock in a stowed position and become inaccessible to occupants.
The risk: An inaccessible seat belt that cannot restrain an occupant, increases the risk of injury in a crash.
The remedy: Dealers will replace the driver and/or passenger seat belt retractors, free of charge. Owner notification letters were mailed September 19, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242441390.
General Motors, LLCManufacturer number N242441390View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 10
Interior & seats
Filed Apr 14, 2026
Fire reported

The heated seat option burned the seat right thru. It’s a fire hazard because the wiring for the heated seats burned right through the cloth seat. so you have a wire issue under a combustible material like the clothing material in a car seat.

NHTSA ID
11731049
Incident
Apr 12, 2026
Brakes
Filed Mar 23, 2026

On 3/21/2026 @ approximately 1:45 PM I was driving down a local road @ approximately 25MPH. While approaching a stop sign, I attempted to stop the vehicle, I applied the brakes and the brake pedal dropped serval inches and became hard felt like it hit the floor of the vehicle. The vehicle continued through the intersection. **There was NO warning message before the vehicle brakes failed to function as designed** There were children attempting to cross the street at the intersection, I blew my horn to alert the children, thank God that they Stopped and did not hit by the car. After the vehicle was brought to a stop there was a message Brake system failure.

NHTSA ID
11726366
Incident
Mar 21, 2026
Interior & seats
Filed Feb 10, 2026
1 injury reported

The contact owns a 2025 Chevrolet Corvette. The contact stated that there was a strong chemical odor coming from the seats. The contact had experienced headaches, burning eyes, respiratory issues, and inflamed lungs. The contact stated that he had temporarily stopped driving the vehicle, and upon driving the vehicle a month later, the contact became aware that the strong chemical odor was the cause of the injuries. The contact had received medical assistance and a new inhaler. The vehicle was taken to the dealer, where the contact was informed that the strong chemical odor would dissipate after some time. The contact stated that the issue could cause significant health problems in the meantime. The contact had stopped driving the vehicle. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 25.

NHTSA ID
11716986
Incident
Feb 10, 2026
Mileage
25 mi
EnginePowertrain (other)
Filed Feb 5, 2026

Intermittent drivability issue involving the transmission during takeoff from a complete stop, most noticeable in heavy traffic and stop and go conditions. Vehicle shudders and lurches when accelerating from a dead stop, with a sensation similar to being hit from behind followed by abrupt engagement. This creates unpredictable launch behavior and raises concern for safe acceleration in traffic, including potential risk when entering intersections or merging. In addition, vehicle has a recurring squeaking noise on cold start that sounds like a belt or pulley related issue. Also experiencing an HVAC airflow malfunction where the center dash vents initially blow air, but within about 30 seconds the center vents stop and airflow shifts to lower vents and or upper dash vents only, affecting normal climate control and potentially defogging or visibility depending on conditions. Issue has been reported to authorized service centers, but the transmission concern has been difficult to duplicate and remains unresolved.

NHTSA ID
11715879
Incident
Mar 24, 2025
Filed Nov 3, 2025

Water trapped under vehicle and in the doors of the vehicle!

NHTSA ID
11697148
Incident
Apr 14, 2025
Fuel system
Filed Oct 27, 2025

The contact owns a 2025 Chevrolet Corvette. The contact received notification of NHTSA Campaign Number: 25V536000 (Fuel System, Gasoline); however, the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact called a local dealer and was advised to bring the vehicle to their location, and the vehicle could remain at the dealer until the part became available to repair the vehicle. The contact declined the suggestion. The manufacturer was not informed of the issue. The contact had not experienced a failure.

NHTSA ID
11695865
Incident
Aug 21, 2025
Other / unspecified
Filed Oct 14, 2025

When having the stock tires changed to all-season tires, the technician found a rear wheel with 2 cracks in the inside bead area. Car had about 8500 miles and an inspection of the old tires showed no damage to the tread or sidewall. No leaking had been noted.

NHTSA ID
11693301
Incident
Sep 12, 2025
Driver assistance
Filed Sep 3, 2025

The contact owns a 2025 Chevrolet Corvette. The contact stated that while operating the vehicle, the Forward Collision Avoidance alert button was pressed but the Forward Collision Avoidance system failed to activate. The cause of the failure was not yet determined, and the vehicle was not repaired. The local dealer was made aware of the failure. The manufacturer was not yet contacted. The failure mileage was 10.

NHTSA ID
11684674
Incident
Feb 24, 2025
Mileage
10 mi

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

PIT6517C

This PI advise dealers If U3000 is present, follow the correct service doc by Symptom Byte before contacting PQC; if not present, verify the camera is clean, then contact PQC if no issue is found.

PIT5099J

PI to help diagnose A/C concern

PIP6089B

This preliminary information advises dealers that engine part numbers 12731949, 12739909 and 12716295 have been placed on restriction. Dealers are instructed to order these engines through the Technical Assistance Center.

PIT6517B

This PI advise dealers If U3000 is present, follow the correct service doc by Symptom Byte before contacting PQC; if not present, verify the camera is clean, then contact PQC if no issue is found.

662.30

• Improvements to audio system performance. • Fixes to help ensure proper functionality for the center display

662.30

• Fixes to help ensure successful vehicle software updates. • The active cabin ventilation feature will operate more reliably. • Additional protection for the health of your battery and updates to help prevent excessive battery drain and overheating. • Improvements to provide more accurate speed limit detection on the driver’s display. • Improvements to the availability of driver assistance features and fewer notifications or warnings. • Fixes to help ensure driver assistance features remain functional when the windshield freezes. • Fixes to help prevent loss of Performance Data Recorder functionality and to protect battery health. • The Transmission Fluid Life gauge will reset properly and show a more accurate reading. • The eAWD indicator will activate less frequently during normal driving conditions. • Fixes a known iPhone 15 charging issue that affects some devices

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Chevrolet Corvette by model year
YearComplaintsRecallsInvestigationsIssue Index
2025Viewing103062.5
2024202056.4
2023241052.5
2022201042.0
2021122054.1
2020344053.1
20191471042.7
2018511040.6
20172554051.5
20161032046.4
2015645047.6
2014615159.6
2013820035.8
2012561043.7
2011851041.3
2010840035.0
20091510034.6
20085400037.8
20073402249.4
20063655456.6
20055326456.2
20042174253.7
2003853157.2
20021573148.8
20012033252.6
20002774358.2
19993084558.8
19983994557.3
19971537456.1
1996441251.1
1995321151.1
1994291245.5
1993222155.4
1992722—
1991243157.6
1990344560.3
1989154259.2
1988165351.3
1987213557.7
1986155559.6
1985163453.5
1984146258.6
1982020—
1981620—
1980320—
1979320—
1978120—
1977130—
1976120—
1975420—
1974030—
1973010—
1972010—
1971010—
1970010—
1969020—
1968020—
1967010—
1966110—
1965010—
1964100—
1960100—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.