2014 Chevrolet Corvette

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Known Fuel Tank crack GM Memo "Special Coverage Adjustment 17469 Fuel Leaks at the Primary Fuel Pump Module Flange", whose previous warranty extension has expired and shouldn't be! GM assumes no responsibility for notifying vehicle owners who purchased used vehicles from non-dealers, which is what I did. I never received any notices about this leak from them since 2018, when I bought the vehicle used from a non-GM dealer. I just recently discovered the leak and had it repaired for $ 5,300.00. I had been driving a vehicle that could have exploded for over 7 years and did not know it. There must be others who are still driving these without knowing. Below is my request to GM to reconsider their 'not covered' response to my email. I suggest that a known Special Coverage Adjustment 17469 Fuel Leaks at the Primary Fuel Pump Module Flange of the gas tank is a life-threatening issue and should never expire! Especially, since many of us bought these vehicles used, 2018 in my case, and have NEVER received any notifications from dealers or GM about this issue. How many others are still outstanding and could blow someone up? The pictures below were taken at my Watson Chevrolet dealer in Tucson, AZ this month, which shows that the crack is exactly what was outlined in your publication 17469, that I never received. Total bill was $5,330.89 (copy attached). I am asking GM to reimburse me for this horrible adventure, not to mention the danger that I've been in for these many years. While I should have detected this issue sooner, how was I to know? I finally gave a friend a ride who said she smelled a really bad gas odor, which led me to the dealer! Now, GM says "you're too late" for us to cover our known defect? Again, this is a life-threatening issue, and your warranty should never expire!

NHTSA ID

11699673

Incident

Nov 1, 2025

The contact owns a 2014 Chevrolet Corvette equipped with Silver's North America NEOMAX coil-overs. The contact stated that while driving through a parking garage at less than 10 MPH, there was an abnormal popping sound coming from the vehicle after driving over a speed bump. The rear driver’s side of the vehicle lowered as the subframe detached from the vehicle. Due to the failure the vehicle remained stuck in the parking garage because the vehicle could not be towed out of the parking garage. The contact also stated that the vehicle could not be moved without causing further damage to it. The contact stated that the vehicle became an obstruction to the other motorist entering the parking garage. The manufacturer was notified of the failure, and an agent attempted to assist the contact; however, the agent stated that any attempts to move the vehicle could be dangerous and cause more damage to the vehicle. The part was not yet replaced. The failure mileage was approximately 6,000.

NHTSA ID

11694955

Incident

Oct 21, 2025

Mileage

6,000 mi

The contact owned a 2014 Chevrolet Corvette. The contact stated that while trying to get out of parallel parking, the accelerator was depressed, and the vehicle jumped. There were no warning lights illuminated. As a result, the vehicle crashed into the vehicle that was in front. The contact snapped her neck. No medical assistance was needed. No police report was filed. The vehicle was taken to the dealer to be repaired however the failure persisted four more times. On a separate occasion, the vehicle would accelerate on its own without any reason, the contact would turn the vehicle off and back on, to drive the vehicle back to normal conditions. The vehicle was taken to the dealer where unknown repairs were completed. The dealer informed the contact that the gas pedal had glue on it. The manufacturer was made aware of the failure. The failure mileage was 4,400.

NHTSA ID

11646472

Incident

Jan 13, 2022

Mileage

4,400 mi

The electric power-steering assist is failing while my vehicle is in motion. I lose power steering and have to use significantly more effort and may lead to a crash, at any speeds. I was driving on the highway when this happened, although it has happened at slower, neighborhood speeds. When this happens, I see a warning message on the dashboard stating the power-steering assist failed and service power steering, drive with caution and the steering is all non-power steering. At times, when I stop the car, and turn the power off, and re-start the car, the power steering works again for a short period of time, and then fails again. This is extremely dangerous. I cannot find any recalls on my car VIN # for this issue for the 2014 Corvette, but see the exact symptoms for the 2017 Corvette (GM' number for this recall is N182182760). Help....please!

NHTSA ID

11635123

Incident

Jan 7, 2025

09/30/2024 The smell is gasoline is emanating from the driver side after I put gas at a local gas station. A short while after I arrived home, the smell of gasoline was still strong. I observed a puddle of gas by the driver side door underneath the gas filler. I have not attempted to start the car until I know it is safe to move to a local dealership or mechanic. Any assistance would be greatly appreciated.

NHTSA ID

11617373

Incident

Sep 28, 2024

The contact owns a 2014 Chevrolet Corvette. The contact stated that while operating the vehicle, upon inspection of the engine compartment, the contact became aware of a fuel leak; however, the location of the leak was unknown. The contact was made aware of the Chevrolet Special Coverage Program: 17469 (Cracks on the Top Surface of Fuel Tank Fuel Pump Module); however, the Extended Warranty Coverage had expired before the repair was performed. The local dealer was contacted, but the vehicle was not diagnosed or repaired because the warranty had expired. The manufacturer was not made aware of the failure. The failure mileage was approximately 13,000.

NHTSA ID

11616903

Incident

Jan 15, 2023

Mileage

13,000 mi

Earlier in the year I called GM about getting my Navigation updated. I ask when the next update would made current. I was told it would probably be in May. I decided to wait until then and it would be more accurate. When I called, they told me that GM had decided not to furnish a new update. I then tried to order one for last year and they could not update that either. I was willing to pay for it. With all the changes in highway's, it is dangerous to try to use it. They sold me the navigation and then made it obsolete. They did Bluetooth the radio but not the navigation. This is a safety hazard, and I feel the least they could do is charge me for the update and furnish it. It is still accurate except for new streets and there are a lot of changes. Help!

NHTSA ID

11614608

Incident

May 1, 2024

The vehicle fails to keep the engine cool when idling or traveling at low speeds and in low gears. When at a stop light, the engine temperature quickly increases to unsafe temperatures, and has even had to be shut off and went up in steam from the engine. Coolant level was and is still full. I believe the cooling fans fail to stay on, maybe due to being turned off on the highways, and therefore fail to turn back on after exiting the highway.

NHTSA ID

11566612

Incident

Jun 10, 2023

This preliminary information communicates information about how to determine if a wheel and tires size change is available.

This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This Preliminary Information communication provides information to the technician about vehicles that have had multiple repair attempts that are being performed on customer’s vehicles that exhibit vibration conditions without utilizing the support of General Motors Technical Assistance Center. If valid vibration frequency or Road Force Variation data has been collected and a repair attempt does not correct the customer complaint, contact General Motors Technical Assistance Center for further support. For any vehicles that remains unrepaired after being at the dealer for three days or more and a related bulletin or PI is not found, contact General Motors Technical Assistance Center for further support.

New Vehicle Monitoring Programs Section in IVH