1997 Chevrolet Corvette

IN 2001, GENERAL MOTORS (GM) ISSUED CUSTOMER SERVICE CAMPAIGNS 1044 AND 1044A TO ADDRESS A CONDITION WHERE THE STEERING COLUMN WOULD FAIL TO UNLOCK DURING THE INITIAL KEY-IN AND START-UP IN CERTAIN MY 1998-2000 CORVETTE VEHICLES.HOWEVER, ODI CONTINUED TO RECEIVE COMPLAINTS CONCERNING STEERING COLUMN LOCKUP ON CORVETTE VEHICLES.AS A RESULT, PE02-054 WAS OPENED AND LATER UPGRADED TO EA02-031 FOR MY 1997-2001 SUBJECT VEHICLES.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN VEHICLES SERVICED THROUGH THE CAMPAIGNS, AS WELL AS, FAILURES IN MY 1997-2003 SUBJECT VEHICLES NOT INCLUDED IN THE CAMPAIGNS.(NOTE: THE MANUFACTURER FAILURE DATA ABOVE IS LIMITED TO MY 1997-2003 VEHICLES THROUGH 10/17/2003.)ON FEBRUARY 6, 2004, GM NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 1997-2004 CORVETTE VEHCLES EQUIPPED WITH MANUAL TRANSMISSIONS AND MY 1997-2000 CORVETTE VEHICLES WITH AUTOMATIC TRANSMISSIONS.THE NOTIFICATION STATED THAT IF THE VOLTAGE AT THE POWERTRAIN CONTROL MODULE (PCM), WHICH WAS DESIGNED TO SHUT DOWN THE FUEL SUPPLY WHEN THE STEERING COLUMN FAILED TO UNLOCK AND THE CUSTOMER TRIED TO DRIVE THE VEHICLE, IS LOW OR INTERRUPTED, THE FUEL SHUT OFF MAY NOT OCCUR.AS A RESULT, THE CUSTOMER COULD DRIVE THE VEHICLE WHILE THE STEERING COLUMN WAS LOCKED CAUSING THE DRIVER TO LOSE STEERING CONTROL AND POSSIBLY CRASH WITHOUT WARNING.GM WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE PCM REPROGRAMMED FOR MANUAL TRANSMISSION VEHICLES AND THE ELECTRIC COLUMN LOCK DISABLED FOR AUTOMATIC TRANSMISSION VEHICLES.ODI WILL MONITOR THE EFFECTIVENESS OF THE REMEDY IN THE MANUAL TRANSMISSION VEHICLES AND TAKE FURTHER ACTION IF WARRANTED.

SEE RESUME IN REPOSITORY.

ODI OPENED THIS EA00-009 ON MARCH 16, 2000, TO CONTINUE ANALYSES BEGUN UNDER PRELIMINARY EVALUATION PE99-076.THE ALLEGED DEFECT: LAP BELT WEBBING IN BOTH SEATING POSITIONS TENDS TO FOLD OVER WHILE ENTERING THE RETRACTOR OPENING.THESE FOLDS FREQUENTLY IMPEDE PROPER WEBBING RETRACTION.IF THE RETRACTOR HAS BEEN INADVERTENTLY TOGGLED INTO AUTOMATIC LOCK RETRACTOR (ALR) MODE BY BEING EXTENDED TO ITS FULL LENGTH, IT MAY FAIL TO RESET ITSELF TO THE NORMAL EMERGENCY LOCK RETRACTOR (ELR) MODE.SUCH A CONDITION HAS BEEN SHOWN TO RENDER THE ACTIVE RESTRAINT UNUSABLE.CONCLUSION: GM WILL REMEDY THE ALLEGED DEFECT IN 71,569 SUBJECT VEHICLES BUILT PRIOR TO AUGUST 1999 BY ADDING WEBBING GUIDE INSERTS TO THE LAP RETRACTOR OPENINGS OF BOTH SEATING POSITIONS TO PREVENT THE ADMISSION OF FOLDED WEBBING ONTO THE RETRACTOR SPOOL.THIS ENGINEERING ANALYSIS HAS BEEN CLOSED.

There is no summary currently available

DRIVER SEAT ELECTRIC FASTENING MOUNTING WEAR IS TOO DEFECTIVE AND HAS TO BE REPLACES. IT MOVES IN AND OUT , SEAT IS MOVING BACK AND FORTH IN ALL POSITIONS. GM REFUSES TO RECALL THEIR PROBLEM.

NHTSA ID

11319906

Incident

Mar 3, 1997

Mileage

2,300 mi

FILLED GAS TANK..NEXT DAY GAS LEAKING WITH HEAVY GAS FUMES..MOVED CAR OUT OF GARAGE AND PARKED IN THE STREET..

NHTSA ID

11291528

Incident

Dec 21, 2019

Mileage

65,000 mi

TL* THE CONTACT OWNS A 1997 CHEVROLET CORVETTE. WHILE ATTEMPTING TO DRIVE IN REVERSE, THE ENGINE STALLED AND THE STEERING WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER STATED THAT THE VEHICLE WAS PREVIOUSLY SERVICED ACCORDING TO NHTSA CAMPAIGN NUMBER: 04V060000 (STEERING). THE APPROXIMATE FAILURE MILEAGE WAS 86,000.

NHTSA ID

10643827

Incident

Sep 13, 2014

Mileage

86,000 mi

TL* THE CONTACT OWNS A 1997 CHEVROLET CORVETTE. THE CONTACT SMELLED A STRONG FUEL ODOR COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE GASKETS AROUND THE FUEL PUMP WERE LOOSE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 133,000.

NHTSA ID

10640872

Incident

Jan 18, 2012

Mileage

133,000 mi

THE CHEVROLET CORVETTE WAS STARTED IN THE COURTHOUSE PARKING LOT MOVING IN REVERSE WITH THE STEERING WHEEL LOCKED IN PLACE NARROWING AVOIDING PEDESTRIANS. THE VEHICLE COULD BE MOVED IN EITHER DIRECTION, BUT THE STEERING WHEEL COULD NOT BE UNLOCKED AND SUBSEQUENTLY TRANSPORTED TO PRINCETON CHEVROLET [FORMERLY KNOWN AS SUPERIOR CHEVROLET] IN LAWRENCEVILLE, NEW JERSEY FOR REPAIR. DURING PREVIOUS SERVICE, THE VEHICLE WAS INSPECTED FOR RECALLS INCLUDING THE STEERING DEFECT WITH THE MANAGER STATING THAT ALL RECALLS WERE COMPLETE. THE JUNE 26, 2013 DEALER STEERING REPAIR INVOICE MAKES NO MENTION OF THE SERVICE RECALL, THE MANAGER EXPLAINING THE JUNE 25, 2013 INCIDENT WAS UNRELATED TO THE STEERING DEFECT AND SAFETY RECALL. THE DEALERSHIP HAS REFUSED TO ACKNOWLEDGE OR RESPOND TO OUR INQUIRIES REFERENCING THE "ELECTRONIC COLUMN LOCK SYSTEM" PRODUCT SAFETY RECALL [04006C] WHICH STATES;" GENERAL MOTORS HAS DECIDED THAT A DEFECT, WHICH RELATES TO MOTOR VEHICLE SAFETY, EXISTS IN CERTAIN 1997-2004 MODEL YEAR CHEVROLET CORVETTE VEHICLES.WHEN THE VEHICLE IS STARTED, IT UNLOCKS THE STEERING. TWO CONDITIONS CAN PREVENT STEERING WHILE THE VEHICLE IS MOVING: ... IF ONE OF THESE CONDITIONS OCCURS, A CRASH COULD OCCUR WITHOUT WARNING." [PG 1 RECALL BULLETIN NO.: 04006C] THE RECALL SPECIFICALLY WARNS DEALERS; "WHENEVER A VEHICLE SUBJECT TO A RECALL ... IS IN YOUR DEALERSHIP FOR SERVICE ... YOU MUST TAKE THE STEPS NECESSARY TO BE SURE THE RECALL CORRECTION HAS BEEN MADE BEFORE ... RELEASING THE VEHICLE." [PG 28 RECALL NO.: 04006C] WE REQUEST NHTSA INVESTIGATE THE FAILURE OF GENERAL MOTORS TO PROMPTLY ALERT OWNERS WITH THE LOCKING STEERING DEFECT, WHY THE VEHICLE WAS RELEASED BY THE DEALER WITHOUT VERIFYING THE RECALL STEERING STATUS, AND WHETHER THE REPAIR PERFORMED AT PRINCETON CHEVROLET ON JUNE 26, 2013 WAS THE REPAIR PROCEDURE OUTLINED IN GM SERVICE BULLETIN NO. 04006C. *TR

NHTSA ID

10594470

Incident

Jun 25, 2013

Mileage

100,020 mi

TL*THE CONTACT OWNS A 1997 CHEVROLET CORVETTE. THE CONTACT STATED THAT THE VEHICLE STEERING LOCK BOX WAS NOT OPERATING PROPERLY AND THE VEHICLE STALLED. THE CONTACT MENTIONED THAT THE CONTROL STEERING LOCK WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER PREVIOUSLY FOR REPAIRS UNDER RECALL NHTSA CAMPAIGN ID NUMBER: 04V060000 (STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE). THE FAILURE RECURRED. THE DEALER WAS CONTACTED WHO EXPLAINED THAT THE MANUFACTURER WAS ONLY REQUIRED TO PAY FOR RECALL REPAIRS ONCE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 268,000.

NHTSA ID

10474064

Incident

Sep 1, 2004

Mileage

40,000 mi

TL* THE CONTACT OWNS A 1997 CHEVROLET CORVETTE C5. THE CONTACT WAS TRAVELING 55 MPH WHEN THE VEHICLE DECELERATED INDEPENDENTLY AND FAILED TO ACCELERATE OVER 30 MPH. THE SERVICE ENGINE WARNING LIGHT ALSO ILLUMINATED INTERMITTENTLY. THE FAILURE WAS RESOLVED TEMPORARILY WHEN THE ENGINE WAS RESTARTED. THE VEHICLE WAS NOT TAKEN TO THE DEALER, BUT THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 48,000.

NHTSA ID

10429038

Incident

Aug 15, 2011

Mileage

48,000 mi

THERE APPEAR TO BE MANY VERIFIED COMPLAINTS ABOUT THE SEATS MOVING UNDER ACCELERATION AND/OR BRAKING IN THE 1997-2004 CORVETTES. WHY HAVEN'T YOU REQUIRED CHEVROLET TO FIX THIS? *TR

NHTSA ID

10395396

Incident

Apr 10, 2011

This Preliminary Information communicates diagnostic information to dealership techs to assist them in diagnosing either a "Service Column Lock" or a "Pull Key, Wait 10 Seconds" message on the DIC.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.