RoadVitals

1996 Chevrolet Impala

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
88
Latest Aug 25, 2014
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Mar 23, 2006
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
4

Overview

Our database contains 88 NHTSA owner-reported complaints for the 1996 Chevrolet Impala, most frequently naming the visibility, steering and electrical categories. 1 safety recall has been issued covering this model year; 2 NHTSA investigations name it; and 24 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
06E026000

EXTERIOR LIGHTING

Mar 23, 2006
61,944 units potentially affected
The defect: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
The risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
PRO-A MOTORS, INC.View on NHTSA.gov

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect.

EA99003ClosedEngineering Analysis

COOLANT FIRES

Opened Jan 13, 1999
Closed Aug 17, 2000

There is no summary currently available

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
PE96001ClosedPreliminary Evaluation

REAR WHEEL SEPARATION

Opened Jan 4, 1996
Closed May 31, 1996

INFORMATION OBTAINED FROM GM INDICATES THAT FURTHER INVESTIGATION TO DETERMINE THE CAUSE OF WHEEL SEPARATIONS IS WARRANTED.IN GM'S RESPONSE DATED APRIL 26, 1996, GM STATED THAT:GM HAS NOT IDENTIFIED ANY DEFECT IN THE MANUFACTURE OF THE SUBJECT VEHICLES WHIH MAY CONTRIBUTE TO WHEEL SEPARATION.INVESTIGATION AS TO THE ROOT CAUSE OF WHEEL SEPARATIONS IS CONTINUING.THE RESULTS OF THESE FURTHER INVESTIGATIONS ARE REQUIRED TO ASSESS THE PROBABILITY OF ANY FUTURE INCIDENTS . . .

SUSPENSIONLed to recall 96V245000

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

View all 88
Electrical
Filed Aug 25, 2014
Crash reported

TL* THE CONTACT OWNED A 1996 CHEVROLET IMPALA. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V355000 (ELECTRICAL SYSTEM). WHILE DRIVING 50 MPH, THE VEHICLE STALLED AND CRASHED INTO A DITCH. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID
10628184
Incident
Jun 4, 2013
Other / unspecified
Filed Aug 2, 2014

BACK IN NOVEMBER 1995 I PURCHASED A NEW 1996 CHEVROLET IMPALA. I BROUGHT THE VEHICLE TO MY HOME AND DID A COMPLETE VEHICLE INSPECTION. WHAT I FOUND WAS THE DEALERSHIP LANAN CHEVROLET OF WOBURN MASSACHUSETTS DID A POOR JOB PREPPING THE VEHICLE FOR DELIVERY. WHAT I FOUND WAS THE LUG NUTS FOR THE WHEELS, ALL WERE LOOSE. I GOT MY TORQUE WRENCH AND TORQUED THE WHEEL NUTS TO THE 100FT LBS. I ALSO FOUND THE FRONT END COMPONENTS WERE NOT GREASED. I CALLED UP THE DEALERSHIP AND TOLD THEM THEY DID A LOUSY JOB.. TODAY 2014 SINCE GM HAS 30 MILLION RECALLS I THOUGHT I WOULD CHECK MY VEHICLES FOR ANY RECALLS . WHAT I FOUND WAS , THE LOOSE LUG NUTS ARE LISTED AS AN INCOMPLETE RECALL ON THIS VEHICLE. SINCE NOV 1995 THESE LUG NUTS HAVE BEEN REMOVED AND RE TORQUED ABOUT 50 TIMES. I CALLED THE DEALERSHIP TO CLEAR THIS RECALL FROM THE GM DATA BASE AND THE SERVICE GUY SAYS YOU HAVE TO BRING THE VEHICLE IN ..THIS IS STUPID ! *TR

NHTSA ID
10618379
Incident
Nov 24, 1995
Mileage
23 mi
Fuel system
Filed Oct 12, 2006

FUEL PUMP FUSE BLOW OUT. THE CAR CUTS OFF AND STOPS WHILE DRIVING, BLOWING OUT THE FUSE. WHEN A NEW FUSE IS INSTALLED AND THE ENGINE IS STARTED, IT BLOWS OUT AGAIN. THE PROBLEM IS CAUSED BY A FAULTY WIRING HARNESS TO THE FUEL PUMP ASSEMBLY. THE WIRING ON THE FUEL PUMP SENDER UNIT MELTS AND PEELS BACK THE INSULATION, CAUSING THE BARE WIRES TO TOUCH AND SHORT AGAINST THEMSELVES OR GROUND OUT AGAINST THE CAR. THIS OCCURS RIGHT AT THE TOP OF THE FUEL PUMP TANK ON THE SENDER ASSEMBLY OR JUST INSIDE THE TANK. THE FUEL PUMP WIRING HARNESSES ON THESE VEHICLES ARE PROBLEMATIC AND DEFECTIVE, POTENTIALLY CAUSING A FIRE IN THE FUEL TANK AND EVENTUALLY A CATASTROPHIC EXPLOSION. A NEW FUEL PUMP SENDER (OEM PART NO. 25028955) WAS REPLACED IN ADDITION TO A NEW ELECTRIC FUEL PUMP, AND NEW FUEL FILTER. *JB

NHTSA ID
10170692
Incident
Oct 8, 2006
Mileage
83,439 mi
Suspension
Filed Mar 26, 2005

CHEVROLET DEALERSHIP WILL NOT HONOR THE RECALLS YOU HAVE PLACED ON THE CAPRICE CAR I HAVE. *AK

NHTSA ID
10114771
Incident
Mar 26, 2005
Body & structure
Filed Jul 30, 2004

THE CONSUMER NOTICED THAT WHEN IT RAINED, THE PASSENGER'S SIDE FLOOR WAS SOAKED DUE TO A LEAK INSIDE THE VEHICLE. *AK *SC *JB

NHTSA ID
10079741
Incident
Jun 23, 2004
ElectricalFuel system
Filed Jun 30, 2004

(1) WHILE TRAVELING THRU LAUGHLIN, NV TRAVELING WEST ON HWY 163, CAR ABRUPTLY QUITS. FUEL PUMP FUSE BLOWN. SUSPECT DYING FUEL PUMP. INSTALL NEW FUSE, TRAVEL ANOTHER 30 MILES UP HWY 95...CAR DIES AGAIN. THIS TIME, NO BLOWN FUSE. FUEL PUMP WILL NOT RUN. TOW VEHICLE TO FINAL DESTINATION (LAS VEGAS). (2) PULLED THE TANK, REMOVED THE SENDING UNIT FOR PUMP REPLACEMENT. QUICKLY NOTICED THE PROBLEM. THE FUEL PUMP WIRING INSIDE THE TANK HAD SHORTED OUT. INSULATION BURNT COMPLETELY OFF OF THE PRIMARY PUMP POWER WIRE AND SHORTED INTO THE FUEL QUANTITY GROUND WIRE. CONNECTOR AT TOP OF SENDING UNIT MELTED. (3) REPLACE SENDING UNIT, FUEL PUMP, STRAINER AND FUEL FILTER. *AK

NHTSA ID
10079043
Incident
Jun 22, 2004
Mileage
92,500 mi
Steering
Filed Apr 28, 2004

INABILITY TO CONTROL THE STEERING ON ROUGH ROADS. STEERING IS VERY LOOSE WHILE DRIVING AT ALL SPEEDS. ALSO, VEHICLE DARTS IN BOTH DIRECTIONS WHILE BRAKING. *AK

NHTSA ID
10071789
Mileage
40,000 mi
Steering
Filed Mar 2, 2004

POWER STEERING INTERMITTENTLY LOCKS UP DURING TURNS AT LOW SPEEDS. THIS SAME THING HAPPENED 3 YEARS AGO. CHEVROLET DEALERS AND CUSTOMER SERVICE BOTH DENY ANY EVIDENCE OF A RECURRING PROBLEM WITH IMPALAS ALTHOUGH THE NHTSA WEB SITE AND AN IMPALA OWNERS' WEB SITE BOTH LIST NUMEROUS OCCURRENCES OF THIS MALFUNCTION. THIS IS A VERY DANGEROUS SITUATION THAT RENDERS THE CAR TEMPORARILY OUT OF CONTROL. *AK

NHTSA ID
10060216
Incident
Feb 26, 2004

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

17-NA-073

EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

PIP4723F

FUEL SYSTEM, GASOLINE; SERVICE BRAKES, HYDRAULIC

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

PIP4723D

ELECTRICAL SYSTEM

This Preliminary Information communicates to the dealer the process for downloading or updating operating software for the Tire Pressure Monitor, Active Fuel Injector tester, multi media tester, PICO Scope, GR8 starting/charging tester  and Vehicle Data Recorder tools, giving website address and step by step instructions to complete the update.

PIC4696E

EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES; EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.  E version update is to add administrative details.

17NA073

EQUIPMENT

This warranty administration bulletin provides information regarding the field action courtesy transportation policy.

PIC4696D

EQUIPMENT

This Preliminary Information communication provides information to the technician on how to unlock radios that are Delco TheftLock. Technician will use the radio to get the scrambled code. Technician will need to contact the radio unlock center to retrieve the unlock code from the scrambled code.  The PI update to version D is to advise the unlock procedure is temporarily unavailable.

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Compare model years

Complaint and recall counts across every year of this model

Chevrolet Impala by model year
YearComplaintsRecallsInvestigationsIssue Index
2020150049.1
2019281052.7
2018591045.3
20171160039.1
20161110041.3
20152993050.3
201463112257.3
20132701038.4
20122583051.6
20115052045.1
20104414048.6
20098245050.4
20088102151.8
20076273051.8
20065242156.2
20056094051.9
20041,0727052.8
20036948157.9
20027957260.4
200174210262.8
200081810263.4
1999400—
1998200—
1997100—
1996Viewing881244.9
1995441143.5
1994151142.6
1993210—
1992010—
1991010—
1987100—
1985111—
1984001—
1983320—
1982230—
1981220—
1980030—
1979230—
1978030—
1977131—
1976010—
1974030—
1973010—
1972020—
1971040—
1969240—
1968020—
1967220—
1966320—
1965030—
1963100—
1958100—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.