2013 Chevrolet Suburban

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

The dashboard in 2007-2014 gm trucks and subs break apart. These can shatter when in an accident. There is insufficient bracing and supports to keep the dashboards from cracking and coming apart in pieces. Only remedy is to replace the dashboard or get an aftermarket cap that may or may not hold during an accident. Especially when the airbags is deployed.

NHTSA ID

11721627

Incident

Jan 1, 2026

The contact owns a 2013 Chevrolet Suburban. The contact received notification of NHTSA Campaign Number: 21V053000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11712550

Incident

Jan 21, 2026

On the driver side adjacent to the fuel tank, improper drainage for the body frame caused severe rust. Over time the frame of the vehicle becomes a safety hazard and may cause the frame to crack or split resulting in loss of control to the rear of the vehicle.

NHTSA ID

11708477

Incident

Nov 28, 2025

Bought 2013 suburban brand new and in 2018, on a trip to the mountains for fall break, the car quit with no warning signs, in the middle of the night. The car would not accelerate when gas pedal was pressed and RPM gauge needle “fluctuated erratically” until car came to a complete stop in the middle of the highway! It was a scary and dangerous situation because it was late at night and we were in the mountains with no phone signal. Cars were coming and going both ways on Highway. Eventually people stopped to help us get suburban towed to local Chevrolet dealership and we had to rent a vehicle to get us to where we were initially going to start our fall break. The dealership called a day later to tell us that there were “lose metal pieces” in the transmission, which meant the transmission had to be replaced. We spent $5000 on that new transmission! It was the only way for us to come back home. The car was out of warranty therefore, the manufacturer did not offer any help! This was a very expensive, frustrating, and dangerous fall break in 2018. Please help! We deserve reimbursement because 7 years later, we bought another 2020 Suburban, also brand new and the same thing happened to transmission, last week! We spent $6000 to replace that transmission!

NHTSA ID

11623850

Incident

Sep 28, 2018

My Suburban's dashboard has a crack that extends now to the edge of the airbag compartment door, with a piece now missing and what appears to be something like an airbag visible. I am concerned the airbag will not deploy correctly if / when it is needed. I have called a certified Chevrolet dealer/ repair garage who said this is not an issue listed under Chevrolet's recall, although I have seen numerous other customers express similar concerns and issues as mine. Thank you.

NHTSA ID

11617338

Incident

Sep 25, 2024

The vehicle has exterior side mirrors that fold in. Once folded in the driverside mirror can be powered back out, but the passager side does not. this makes it unsafe to change lanes and identify a vehicle in your blind spot. This malfunction has happen several times on this vehicle. Prior to this vehicle had another 2013 suburban that the same malfunction occurred on. What are the odds of the same malfunction occurring on two seperate vehicles. The vehicle is currently at a mechanic shop that I have asked to check this out. Without this mirror it is unsafe to drive on a multi-lane freeway where changing lanes is necessary.

NHTSA ID

11585191

Incident

Apr 22, 2024

The contact owns a 2013 Chevrolet Suburban. The contact stated that the dashboard had many fractures nearby the air bag enclosure. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer was made aware of the failure, and it was confirmed that the VIN was not included in a recall. The failure mileage was 294,000.

NHTSA ID

11569941

Incident

Jan 22, 2024

Mileage

294,000 mi

Starting approximately 24 months ago the dash on my Suburban started cracking. Now it has cracked in several locations on both the driver's and passenger side of the dash. The cracks on the passenger side go up to the air bag location. Cracks on the driver's side are numerous and getting worse. The driver's side cracks are such that the pieces would come apart in an accident, even if the air bag was not deployed.

NHTSA ID

11548174

Incident

Jun 1, 2021

This Preliminary information communicates direction to find information at www.gmupfitter.com for Police and Special Service Vehicles.

This preliminary information communicates information about how to determine if a wheel and tires size change is available.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.

This Preliminary information communicates the steps on how to save a GDS2 Session Log and upload to a Technical Assistance Case in CX Connect.

This PI Communications information on an alternative product dealers can use to perform 19-NA-255: Wax Coating on Frame Peeling, Metal Shows Corrosion/Rusting due to issue with getting product from current supplier listed in the bulletin.

This preliminary information advises a dealer on how to email GDS2 session logs into Technical Assistance.