1996 Nissan Maxima

TL* THE CONTACT OWNS A 1996 NISSAN MAXIMA. THE CONTACT STATED THAT WHILE SLOWING DOWN AT APPROXIMATELY 5 MPH, THE VEHICLE STALLED AS THE STEERING WHEEL SEIZED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN INFORMED THE CONTACT THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,300.

NHTSA ID

10806661

Incident

Nov 11, 2015

Mileage

100,300 mi

CAR FIRE. MY SON'S CAR CAUGHT ON FIRE WHILE HE WAS DRIVING IT DUE TO A PART NISSAN KNEW WAS DEFECTIVE. THERE IS A RECALL FOR 1997-1999 NISSAN MAXIMAS DUE TO A DEFECT IN THEIR ALTERNATORS THAT CAUSED THEM TO CATCH FIRE. DETAILS ABOUT THE RECALL ARE BELOW. MY SON WAS DRIVING HIS 1996 MAXIMA WHEN THE ALTERNATOR CAUGHT FIRE. LUCKILY, HE ESCAPED WITHOUT INJURY. ALTHOUGH HIS CAR WAS NOT INCLUDED IN THE RECALL, CLEARLY THE PART THAT STARTED THE FIRE IS THE SAME AND IT IS THE PART THAT IGNITED THE FIRE. I SPOKE WITH NISSAN CONSUMER AFFAIRS THREE TIMES OVER THE PAST COUPLE OF WEEKS. I AM CONTACTING YOU BECAUSE I WAS NOT ABLE TO GET NISSAN TO DISCUSS THIS EVENT IN TERMS OF THE SECURITY ASPECT OF IT. UNFORTUNATELY, THEY CHOSE TO LOOK AT IT STRICTLY AS A WARRANTY ISSUE. IT STANDS TO REASON, IF THIS PART WAS IN MY SON'S CAR, IT IS ALSO IN OTHER 1996 MAXIMAS. THE NEXT PERSON WHO EXPERIENCES A CAR FIRE DUE TO A FAULTY ALTERNATOR MAY NOT BE AS LUCKY AS MY SON. NOTE: I BOUGHT BACK THE ALTERNATOR FROM THE SERVICE DEPARTMENT AND I HAVE IT AT HOME. WWW.AUTOMOBILEMAG.COM/AM/1997/NISSAN/MAXIMA/RECALLS.HTML RECALL ID # 02V171000 - ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR RECALL DATE: JUN 24, 2002 MODEL AFFECTED: 1997 NISSAN MAXIMA SUMMARY: ON CERTAIN PASSENGER VEHICLES, ONE OF THE DIODES USED IN THE ALTERNATOR MAY HAVE BEEN DAMAGED WHEN BUILT. THIS CAN EVENTUALLY RESULT IN FAILURE OF THE DIODE AND AN ELECTRICAL SHORT WHICH COULD MELT THE PLASTIC HOUSING. CONSEQUENCE: IF THE COMBUSTIBLE GAS EMITTED BY THE MELTING PLASTIC DOES NOT DISPERSE DUE TO AIR FLOW THROUGH THE ENGINE COMPARTMENT, IT COULD IGNITE AND IN TURN IGNITE THE FAN GUIDE IN THE ALTERNATOR. THE ALTERNATOR WAS REPLACED AT A COST OF $560 UPDATED 10/17/11 *TR

NHTSA ID

10421503

Incident

Aug 8, 2011

Mileage

198,000 mi

MY 1996 NISSAN MAXIMA CAUGHT ON FIRE BY ITSELF IN THE MIDNIGHT, AND IT WAS ALMOST COMPLETELY DESTROYED BY THE FIRE. I RECEIVED THE VEHICLE FROM MY FRIEND AS A GIFT, WHICH WAS IN A VERY GOOD CONDITION. AND I ALSO PAID THE BUCKNER'S AUTO SERVICE CENTER AT KNOXVILLE, TN FOR CHECKING THE CAR IN DETAIL AND GETTING IT REPAIRED. BUT 8 DAYS AFTER, THE CAR WAS ON FIRE. DURING THE 8 DAYS, THE CAR WAS PARKED IN THE PARKING LOT IN FRONT OF MY APARTMENT, AND NOBODY EVER TOUCHED THE CAR. IT'S CLOUDY OR RAINY IN ALL THESE DAYS. THOUGH FORTUNATELY MY WIFE AND I WERE SAFE, WE WERE REALLY SCARED AND MY WIFE WAS AFRAID OF VEHICLES FROM THEN ON. WE HAVE ARRIVED AT THE U.S LESS THAN 2 MONTHS, AND THIS INCIDENT ALMOST COMPLETELY DISRUPTED OUR LIVES. THE FOLLOWING IS THE DESCRIPTION FROM THE KNOXVILLE POLICE DEPARTMENT CRIME REPORT: THE VEHICLE HAD NOT BEEN DRIVEN FOR EIGHT DAYS. INTERVIEWED CAR OWNER, WHO STATES HE HAS BEEN IN THE US FOR ABOUT ONE MONTH, AND HAD RECEIVED THE VEHICLE AS A GIFT FROM A FRIEND. HE SAID THAT HE HAD TAKEN THE CAR FOR REPAIRS AND TO BE SERVICED AT BUCHNERS AUTO REPAIR ON 9/8/2009 AND HAD AN INVOICE OF THE WORK PERFORMED. HE SAID THAT THE CAR HAD NOT BEEN DRIVEN SINCE THEN BECAUSE HE WAS STILL IN THE PROCESS OF OBTAINING HIS DRIVER LICENSE. THERE WAS ONLY AN 8 MILE DIFFERENCE THE INVOICE MILEAGE AND THE CARS ODOMETER READING. INVESTIGATION OF THE VEHICLE REVEALED AN ENGINE COMPARTMENT FIRE. THE CAR WAS LOCKED AND HOOD WAS SECURE WHEN ENG 12 ARRIVED. THEN HAD TO FORCE THE HOOD SINCE THE CABLE DID NOT FUNCTION DUE TO FIRE DAMAGE. AREAS OF HIGH HEAT WERE INDICATED ON THE HOOD OVER THE BATTERY AND FUEL/AIR INTAKE LOCATIONS. ALSO OF NOTE WAS THAT THE COOLING FANS WERE DESTROYED AND ONE HAD FALLEN TO THE GROUND. THIS FIRE IS CONSIDERED TO ACCIDENTAL AND THE CAUSE TO BE A MECHANICAL OR ELECTRICAL MALFUNCTION. THE OWNER DOES NOT HAVE INSURANCE ON THE VEHICLE. SUGGESTED THAT THE OWNER TAKE PHOTOS AND CONTACT BUCHNERS TO CHECK FOR ANY RECALLS OR TO'S FOR THIS VEHICLE. *TR

NHTSA ID

10286192

Incident

Sep 18, 2009

Mileage

206,576 mi

THE AIR BAG LIGHT ON DASH JUST STARTED FLASHING INTERMITTENTLY THEN I JUST SEE THAT THERE IS A RECALL. HOWEVER MY CAR IS 1996. I AM A NERVOUS WRECK TRYING TO DRIVE. *TR

NHTSA ID

10254095

Incident

Dec 30, 2008

TL*THE CONTACT OWNS A 1996 NISSAN MAXIMA. THE CONTACT STATED THAT THE AIR BAG INDICATOR CONSTANTLY FLASHED ON THE INSTRUMENT PANEL. SHE TOOK THE VEHICLE TO THE DEALER AND PAID $125 FOR AN ESTIMATE. THE DEALER STATED THAT THE FAILURE WAS INCAPABLE OF BEING REPAIRED. IN THE SUMMER OF 2007, THE MANUFACTURER STATED THAT THEY WOULD NOT ASSIST IN REPAIRING THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 84,000 AND FAILURE MILEAGE WAS APPROXIMATELY 75,000. UPDATED 11/28/08 *BF THE VEHICLE WAS LOOSING POWER STEERING FLUID. THE DEALER STATED THE PUMP HAD A LEAK. UPDATED 12/02/08. *JB

NHTSA ID

10248340

Incident

May 11, 2007

Mileage

75,000 mi

OF 4 TIRES PURCHASED IN MAY 2008, 3 HAVE FAILED. ONE TIRE WAS REPLACED DUE TO RADIAL TIRE PULL. A SECOND WAS REPLACED DUE TO A BLISTER THAT DEVELOPED ON THE SIDEWALL. A THIRD WAS REPLACED DUE TO A FLAT SPOT THAT WAS DISCOVERED ON THE TREAD, WHICH WAS FOUND WHEN THE TIRE COULD NOT BE BALANCED. ALL 3 TIRES FAILED WITHIN THE FIRST 6,000 MILES OF TREADWEAR. TIRES ARE GOODYEAR COMFORT TREAD. *TR

NHTSA ID

10240484

Incident

Aug 23, 2008

Mileage

185,600 mi

I FACED A RARE (I DON'T KNOW I AM THINKING IT AS RARE) PROBLEM WITH NISSAN MAXIMA. WHEN I WAS DRIVING THE VEHICLE IN DRIVE MODE MY FRIEND, SITTING IN THE OTHER SEAT, ACCIDENTALLY CHANGED THE GEAR TO REVERSE MODE THEN THE STRANGE THING HAPPENED, THE CAR STEERING GOT LOCKED AND THE CAR GOT DECELERATED VERY FAST (AS I WAS APPLYING A BRAKE) AND EVEN THOUGH I CHANGED THE GEAR INTO DRIVE MODE THE CAR WONT PICK ACCELERATION AND BEHAVED AS IT IS IN THE NEUTRAL GEAR. SO, THE CAR STOPPED IN THE MIDDLE OF THE INTERSTATE ON THE LEFT LANE AND WE ALMOST GOT KILLED BY THE ON COMING TRAFFIC. SINCE THE STEERING WHEEL IS NOT MOVING WE ARE NOT ABLE TO MOVE THE CAR TO THE SHOULDER. WHAT WE DID IS WE STOPPED (TURN OFF) THE VEHICLE ON THE INTERSTATE AND CHANGED THE GEAR INTO PARKING AND STARTED IT AGAIN, AFTER "FEW SECONDS" THE CAR FINALLY MOVED. I AM SO SCARED BY THE EVENT AND I WANTED TO REPORT TO SOME ONE AND I THOUGHT MAY BE NHTSA IS THE BEST BET. PLEASE TELL ME WHETHER IT WILL BE THE SAME TO ANY CAR OR WILL THAT BE ONLY ON NISSAN MAXIMA. *TR

NHTSA ID

10222383

Incident

Mar 24, 2008

TL*THE CONTACT OWNS A 1996 NISSAN MAXIMA. THE CONTACT MUST MAKE 5 OR 6 ATTEMPTS IN ORDER TO START THE VEHICLE. OCCASIONALLY, HE MUST DEPRESS THE ACCELERATOR PEDAL TO THE FLOOR FOR THE VEHICLE TO START. THE FAILURE OCCURS EACH TIME HE ATTEMPTS TO START THE VEHICLE, ESPECIALLY AFTER IT HAS BEEN PARKED FOR SEVERAL HOURS. IF THE VEHICLE HAS BEEN DRIVEN AND IS STILL WARM, IT TAKES 2 OR 3 ATTEMPTS TO START. THE MECHANIC SUGGESTED THAT THE FAILURE MAY BE FUEL SYSTEM RELATED AND HE REPLACED THE FUEL PUMP, FILTERS, WIRING HARNESS, AND STARTER. THE CONTACT STATED THAT THE TRANSMISSION IS DIFFICULT TO SHIFT. HE BELIEVES THAT THE ELECTRICAL SENSOR IS NOT READING CORRECTLY. THE PURCHASE DATE AND DEALER INFORMATION WERE UNAVAILABLE. THE CURRENT MILEAGE WAS 157,000 AND FAILURE MILEAGE WAS 143,000.

NHTSA ID

10200988

Incident

Aug 10, 2006

Mileage

143,000 mi

DIAGNOSIS OF VEHICLE PULL (DRIFT) AND/OR STEERING WHEEL OFF-CENTER This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

12 VOLT BATTERY TESTING FOR IN-SERVICE VEHICLES SERVICE INFORMATION The following Service Information lists NNA procedural recommendations for establishing good connections while performing 12V battery testing. These recommendations are expected to promote uniformity during the connection process, therefore reducing the number of incorrect “Test with DCA” and “Replace” results. HINT: If 12 volt batteries are allowed to discharge for a prolonged period of time, battery life may be drastically reduced. This condition may lead to premature battery replacement and customer dissatisfaction. IMPORTANT:  CPX-900 is now an accepted testing tool to use along with or in place of the DSS-5000  CPX-900 operating instructions are found at: https://nissancpx900.midtronics.com/  DSS-5000 operating instructions are found at: https://nissandss5000.midtronics.com/  DCA-8000 is now a required testing tool to be used for all warranty replacement decisions. The DCA-8000 is also a more efficient charger than previously available, and will charge any available 12 volt lead acid battery safely and accurately as long as all precautions and inputs are made correctly. The DCA-8000 operating instructions are found at: https://nissandca8000.midtronics.com/

SILICONE-BASED LUBRICANT OR GREASE CAN DAMAGE ELECTRICAL COMPONENTS SERVICE INFORMATION Do not apply Silicone-based lubricants or grease to, or around, any interior electrical components. To avoid the risk of death or severe personal injury, do not directly spray Silicone-based lubricant or grease, or inadvertently overspray Silicone-based lubricant or grease onto any interior electrical components. These types of lubricants can be detrimental to the proper operation of electrical components.

VEHICLE KEY NOT DETECTED / AUTHENTICATED, ENGINE WILL NOT START This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.

INTELLIGENT KEY REPLACEMENT OR SWAPPING BETWEEN VEHICLES This bulletin has been amended. See AMENDMENT HISTORY on the last page. Discard all previous versions of this bulletin.

WINDSHIELD CRACKING This bulletin has been amended. See AMENDMENT HISTORY on the last page. Please discard previous versions of this bulletin.