2000 Audi A6

VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.

THE SUBJECT VEHICLES ARE EQUIPPED WITH A KNEE BOLSTER LOCATED UNDER THE DASH, NEAR THE DRIVERS KNEES.A WIRING HARNESS IS ALSO LOCATED IN THE DASH, IN THAT SAME AREA.AUDI'S ANALYSIS OF 39 VEHICLES INDICATED THAT THE KNEE BOLSTER WAS RUBBING AGAINST THAT WIRING HARNESS.OVER TIME THE HARNESS SHEATHING WEARS AWAY AND THE WIRES COME INTO CONTACT WITH THE METAL KNEE BOLSTER, RESULTING IN A FIRE. AUDI WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF AUDI A6 VEHICLES, TO ADD A PLASTIC CAP TO THE TOP OF THE KNEE BOLSTER BRACKET, WHICH WILL PREVENT ABRASION TO THE WIRING HARNESS. AUDI WILL RECALL 186,000 MY 1998-2004 AUDI A6 VEHICLES.ODI IS AWARE OF A TOTAL OF 24 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 04V-133.

OF THE 22 TOTAL COMPLAINTS, 11 WERE RECEIVED FOR THE 1999 MODEL YEAR AND 11 FOR THE 2000 MODEL YEAR. AUDI IS CONDUCTING TESTING TO DETERMINE THE ORIGIN AND CAUSE OF THE FIRE.

Gas is pouring out from the top of the gas tank

NHTSA ID

11465549

Incident

May 19, 2022

EACH TIME I FILL THE GAS TANK THERE IS A STRONG SMELL OF LEAKING GAS. NOT CLEARLY IDENTIFIED THE SOURCE BUT FEEL THIS IS A SIGNIFICANT SAFETY RISK.

NHTSA ID

11005938

Incident

Jul 17, 2017

Mileage

135,222 mi

TL* THE CONTACT OWNS A 2000 AUDI A6. THE CONTACT NOTICED STRONG FUMES ENTERING THE VENTS, WHICH AFFECTED THE CONTACT'S BREATHING. THE CONTACT WAS NOT ABLE TO USE THE HEATER OR AIR CONDITIONER. A WEEK LATER, WHILE DRIVING, A FIRE ERUPTED NEAR THE DASHBOARD AND SMOKE CONSUMED THE INSIDE OF THE VEHICLE. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD AND A FIRE INSPECTOR EXTINGUISHED THE FLAMES. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 06V198000 (ELECTRICAL SYSTEM), BUT THE CONTACT DID NOT RECEIVE A NOTIFICATION. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS TOWED AND PARKED. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

10874383

Incident

Jun 10, 2016

THE FIRST TIME THIS CAR HAD ANY PROBLEMS WITH ANYTHING LEAKING WAS A COUPLE DAYS AGO WHEN WE WOKE UP IN MIDDLE OF THE NIGHT TO HOUSE AND GARAGE SMELLING LIKE GAS. ON DRIVER'S SIDE REAR BY PASSENGER DOOR THERE WAS A SMALL LEAK LOOKED LIKE OIL BUT SMELLED OF GAS AND UNDERNEATH CAR YOU CAN SEE WEAR A SMALL CRACK IS AT IN FUEL SYSTEM. I SEE MANY RECALLS FOR SAME THING FOR DIFFERENT YEARS AND COMPLAINTS FILED FOR THIS SAME PROBLEM AND YEAR. NO RECALL NOTICES WAS EVER RECEIVED BY MYSELF OR PREVIOUS TWO OWNERS WHO WAS FRIENDS OR IT WOULD HAVE BEEN FIXED. I AM UPSET BECAUSE NOW IT WON'T BE FIXED UNDER RECALL BECAUSE IT'S BEEN SO LONG HOWEVER THERE WAS NO CLOSE DATE ON REPORTS IT SHOWS SEVERAL THOUSAND CARS NEVER GOT THE REPAIR AND WAS NOT NOTIFIED. THIS IS A HUGE SAFETY ISSUE THAT NOT ONLY CAN START CAR ON FIRE BUT HOUSE ON FIRE IF PARKED IN GARAGE. NOW I AM SUPPOSE TO PAY FOR THE COST ON SOMETHING THAT WAS NOT PUT TOGETHER CORRECTLY AND IS A SAFETY HAZZARD BECAUSE I WAS NOT WARNED ABOUT IT BY MAIL OR WHEN CAR WAS SERVICED AND NEVER HAD TROUBLE TILL NOW AND THERE ARE TONS OF CUSTOMERS YOU ARE NOT HELPING WITH SAME PROBLEM YEAR MAKE AND MODEL OF CAR. IF THIS RESULTS IN DEATH THAN IT WILL BECOME A MORE SERIOUS PROBLEM ON YOUR HAND FOR NOT FIXING A RECALL THAT HAS BEEN KNOWN TO BE PROBLEMS ON SEVERAL YEARS OF AUDI'S AND NOT ALL AUDI OWNERS WAS REACH OR REPAIRS DONE AND NOW WHEN WE ARE FINDING OUT WE ARE BEING TURNED AWAY. IF THIS WAS NOT SOMETHING HAZARDOUS OR LIFE THREATENING THAT'S ONE THING BUT SOMETHING SO DANGEROUS THAT CAN TAKE A LIFE YOU SHOULD MAKE SURE EVERY RECALL THAT IS SAFETY RELATED AND HAZARDOUS FIX REGARDLESS OF WHEN NOTICE IF FOUND. I AM EXPECTING THE RECALLS FOR ALL FUEL RELATED PROBLEMS ON ALL AUDI BE FIXED WHEN CUSTOMERS CALL TO INQUIRE AND NOT BE TURNED AWAY AFTER WE ARE SENT TO DEALER TO HAVE IT LOOKED AT.

NHTSA ID

10852911

Incident

Mar 29, 2016

Mileage

125,549 mi

FIRST THE CAR RAN HOT NO TEMP HAVE CAME ON HAD TO REPLACE MOTOR .....THE COOLING FAN BROKE MADE OF PLASTIC AND CUT MY SERPENTINE BELT INTO ......THEN THE CAR FLOODED AND RUINED THE COMFORT CONTROL MODULE HAD TO REPLACE THIS NOW THE FRONT AXEL IS BROKE AND THE BOOTS FELL APART AND THE BALL JOINTS ARE NO GOOD......

NHTSA ID

10781459

Incident

Jul 1, 2015

HELLO! TODAY I WAS AT THE SAMS CLUB GAS STATION TO FILL UP MY VEHICLE, 2000 AUDI A6 WITH THE 4.2 ENGINE. WHEN I FINISHED, I WENT OVER TO THE DRIVER SIDE, WHERE IVE SEEN A HUGE AMOUNT OF GAS ON THE GROUND. THE FUEL WAS LEAKING REALLY BAD FROM MY CAR. THE SAM'S CLUB EVEN CALLED THE FIRED DEPARTMENT AND THE POLICE THERE TOO. IT LEAKED OUT A LOT COUPLE GALLONS FROM MY VEHICLE. THANKS GOD THE GAS STATION HAD A SMALL INCLINE SO I COULD NOTICE IT RIGHT BEFORE I WOULD DRIVE AWAY. JUST THINKING THAT I WOULD DRIVE AWAY AND SOMETHING SERIOUS WOULD HAPPEN IT SCARES ME. AS I UNDERSTAND A LOT OF AUDIS ARE RECALLED BECAUSE OF THIS ISSUE. MINE IS NOT UNDER THE RECALL. WHAT CAN I DO TO GET MINE UNDER THE RECALL TOO? PLEASE HELP ME. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10670841

Incident

Jan 7, 2015

Mileage

141,590 mi

AFTER FILLING GAS TANK, GAS BEGAN LEAKING AS A STEADY STREAM FROM LEFT FRONT SIDE OF GAS TANK, NEAR THE REAR DRIVER'S WHEEL WELL. OWNER CONTACTED AUDI DEALERSHIP AND AUDI OF AMERICA. OWNER PAID FOR DEALER INSPECTION TO DIAGNOSE LEAKING GAS ISSUE. DEALER STATED THE TANK WAS LEAKING AND NEEDED TO BE REPLACED. AUDI OF AMERICA CONTACTED OWNER ON 3/20/2014 AND STATED THE SERVICE MANAGER OF AUDI OF ANN ARBOR, MI HAD DECIDED THEY WOULD NOT COVER THE REPAIR DUE TO VEHICLE "MILEAGE AND AGE." AUDI OF AMERICA STATED SINCE VEHICLE WAS OUTSIDE OF RECALL RANGE (2001-2005 MY), THEY WOULD NOT ASSIST WITH REPAIRS. INDEPENDENT OWNER RESEARCH SHOWS MULTIPLE LEAKING GAS TANK ISSUES (BROKEN ROLLOVER VALVE NIPPLE) WITH THIS VEHICLE, AND MATCHING PART NUMBERS BETWEEN 2001-2005 MY GAS TANKS AND 2000 MY GAS TANK. *TR

NHTSA ID

10573837

Incident

Mar 17, 2014

Mileage

135,400 mi

FIRST INCIDENT MARCH 2006 LEAKY GAS TANK HAD TO BE REPLACED, COST TO US $2,249.27, AUDI DENIED RESPONSIBILITY. REQUESTED AUDI TO REPORT THIS ISSUE TO AUTHORITIES. SECOND INCIDENT, 7/30/13 (MILEAGE 163,016): VERY STRONG GASOLINE ODOR. THE MECHANIC REMOVED REAR SEAT AND FOUND FUEL STAINING ALL AROUND THE SENDING UNIT. FUEL TANK MUST AGAIN BE REPLACED. THIS WILL BE OUR THIRD TANK COUNTING THE ORIGINAL ONE INSTALLED AT THE FACTORY. IN 2008 AUDI ISSUED SAFETY RECALL CIRCULAR CODE: 2OL8/JY REVISED IN JANUARY 2009. MY FIRST FUEL TANK FAILURE OCCURRED 2 YEARS BEFORE THE RECALL. THE AUDI RECALL COVERS MODEL YEARS 2001 THROUGH 2005. MY CAR IS 2000 WITH THE SAME DEFECT AS IN LATER MODELS. 2000 MODEL SHOULD HAVE BEEN INCLUDED IN THE RECALL. I FIND IT INCREDIBLE THAT AUDI DID NOT KNOW THAT THE IDENTICAL SAFETY DEFECT WAS IN THE 2000 MODEL. THE 2006 FUEL TANK AND PARTS WERE PURCHASED NEW FROM AUDI AND SHOULD BE THE NEWER DESIGN FUEL TANK (IF THERE HAD BEEN ANY REDESIGN BY THEN). ALSO, AS A 2006 FUEL TANK, REPAIRS SHOULD BE COVERED BY THE 2008 RECALL. AUDI DOES NOT APPEAR TO HAVE PUBLICLY RECOGNIZED ITS DESIGN FAILURE, AND WAS NOT EXPLICIT ABOUT THE PROBLEM DETAILS AND THE FIX FOR THE FUEL TANK SAFETY PROBLEM UNTIL THE 2008 RECALL. USING A COPY OF THE 2008 RECALL NOTICE I TELEPHONED CUSTOMER RELATIONS AT AUDI OF AMERICA IN ROCHESTER HILLS, MI (1-800-253-2834). AUDI ASSIGNED ME A CASE NO. #130535300, AND TOLD ME TO TAKE THE CAR TO AN AUDI DEALER. SINCE THE CAR WAS UNSAFE TO DRIVE IT WAS TOWED TO A DEALER ON 8/9/13. I HAVE SPENT $871.25 AT MY MECHANIC'S TO IDENTIFY THE DEFECT AND TO TOW THE CAR TO AUDI. ON 8/19/13 THE AUDI DEALER CALLED TO STATE THAT AUDI WAS NOT RESPONSIBLE FOR THE REPAIR AND REPLACEMENT OF THE FUEL TANK. I AM THE ORIGINAL OWNER WITH SAME ADDRESS AND CAR REGISTRATION, YET NEVER RECEIVED A RECALL NOTICE. WE HAVE BEEN DRIVING A MOLOTOV COCKTAIL.

NHTSA ID

10536289

Incident

Mar 1, 2006

Mileage

78,025 mi

This bulletin provides information on the additional reporting requirements for safety related inquiries.

This informational bulletin explains how to order replacement VIN plates, Safety Certification Labels, etc.

This information bulletin contains instructions for technicans on how to ensure their TAC call goes smoothly.

This communication is issued to inform dealers of updated shipping regulations related to lithium ion batteries.

This communication is issued to remind dealers of the repair validation process for repair group 19. 2005-2019 A3, 1996-2019 A4, 2008-2019 A5, 1992-2019 A6, 2012-2019 A7, 1997-2019 A8, 2019 E-Tron, 2015-2019 Q3, 2010-2019 Q5, 2007-2019 Q7, 2019 Q8, 2000-2019 TT, 2008-2018 R8

This bulletin contains instructions for additional reporting requirements for safety related inquiries (airbag/seatbelts, accidents, fire and overheat damage). 2008-2021A3, 2015-2021A3 Cabrio, 2005-2016 A3 Sportback, 1999-2021 A4, 2010-2021 A4 allroad, 1999-2012 A4 Avant, 2003-2009 A4 Cabrio, 2010-2021 A5 Cabrio, 2008-2021 A5 Coupe, 2018-2021 A5 Sportback, 1999-2021A6, 1999-2011A6 Avant, 2008-2020 A7, 1999-2021 A8, 2008-2019 e-tron, 2019-2021 e-tron quattro, 2015-2021 Q3, 2009-2021 Q5, 2007-2021 Q7, 2019 Q8, 2008-2020 R8 Coupe, 2011-2020 R8 Spyder, 2017-2019 RS3, 2007-2008 RS4, 2008 RS4 Cabrio, 2010-2021 RS5, 2010-2020 RS5 Cabrio, 2016-2018 RS6, 2016-2018 RS7, 2004-2012 S4, 2004-2009 S4 Cabrio, 2010-2021 S5 Cabrio, 2008-2021 S5 Coupe, 2018-2021 S5 Sportback, 2007-2021 S6, 2008-2020 S7, 2007-2009 S8, 2018-2021 SQ5, 2000-2021 TT Coupe, 2001-2021 TT Roadster, 2012 TT/RS Coupe