1998 Audi A6

VOLKSWAGEN OF AMERICA, INC. (VOA) CONDUCTED A SAFETY RECALL (NHTSA RECALL NUMBER 04V133) TO ADD A PLASTIC COVER TO THE TOP SECTION OF THE KNEE BOLSTER CROSSMEMBER TO PREVENT CONTACT WITH THE HEADLIGHT SWITCH WIRING HARNESS.THE SCOPE OF THE ORIGINAL RECALL COVERED MODEL YEARS 1998 THROUGH 2004 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH DECEMBER 2004.THE OFFICE OF DEFECTS INVESTIGATION HAS RECEIVED NINE COMPLAINTS ALLEGING THAT AFTER HAVING THE RECALL REMEDY PERFORMED, A FIRE STARTED IN THE DRIVER'S SIDE DASHBOARD AREA.VOA REPORTS THAT IF THE PLASTIC COVER IS NOT INSTALLED PROPERLY BY THE DEALERS, THE HEADLIGHT SWITCH WIRING HARNESS COULD CONTINUE TO CONTACT THE CROSSMEMBER, RESULTING IN A SHORT AND/OR FIRE IN THE DRIVER'S SIDE DASHBOARD AREA.VOA WILL CONDUCT A NEW SAFETY RECALL TO ADD AN ADDITIONAL (AND LARGER) COVER OVER BOTH THE KNEE BOLSTER CROSSMEMBER AND THE PLASTIC COVER ASSEMBLY INSTALLED IN THE FIRST RECALL.ALL OF THE NHTSA COMPLAINTS AND ALL BUT 3 VOA CLAIMS ARE FOR MY 1998 THROUGH MY 2000.VOA REPORTS THAT BEGINNING IN MY 2001, AUDI EXTENDED THE TIME FOR THE DEBURRING PROCESS OF THE CROSSMEMBER.VOA WAS NOT ABLE TO VERIFY THE CAUSE OF FIRE IN THE MY 2001 AND LATER VEHICLES DUE TO EITHER EXTENSIVE FIRE DAMAGE OR OTHER REASON.THE RATE OF FIRE OCCURRENCE IS SIGNIFICANTLY LESS FOR THE MY 2001 AND LATER VEHICLES. THE RECALL COVERS MODEL YEARS 1998 THROUGH 2000 WITH VEHICLE PRODUCTION DATES OF AUGUST 1997 THROUGH MAY 2000.VOA WILL RECALL 66358 MY 1998-2000 AUDI A6, A6 AVANT, S6, AND S6 AVANT VEHICLES.ODI IS AWARE OF A TOTAL OF 59 WARRANTY, FIELD AND CONSUMER REPORTS FOR THESE VEHICLES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 06V-198.

VWOA HAS RECALLED APPROXIMATELY 28,300 MY 1998-99 A6 VEHICLES IN COLD WEATHER STATES THAT EXPERIENCED THE HIGHEST RATE OF THROTTLE ICING INCIDENTS IN THE SUBJECT VEHICLES (04V-495).THE FAILURE RATE IN THE A4 AND PASSAT VEHICLES IS MUCH LOWER THAN IN THE RECALLED VEHICLES.ODI WILL CONTINUE TO MONITOR THE EXPERIENCE IN THE A4 AND PASSAT VEHICLES.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS FOR THE AUDI A4 OR VW PASSAT VEHICLES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY A CHANGE IN CIRCUMSTANCES. FOR FURTHER DETAILS SEE THE ATTACHED CLOSING REPORT.

COMPLAINTS RECEIVED BY ODI AND AUDI ALLEGE THAT, IN EXTREME COLD WEATHER, THE THROTTLE MAY UNEXPECTEDLY FAIL TO RETURN TO IDLE WHEN THE ACCELERATOR PEDAL IS RELEASED, MAKING IT DIFFICULT TO STOP THE VEHICLE.IN MARCH OF 2004, AUDI PERFORMED A SERIES OF TESTS TO INVESTIGATE THE POSSIBLE CAUSES OF THROTTLE ICING.AUDI CONCLUDED THAT UNDER CERTAIN DRIVING CONDITIONS - ONLY SHORT DISTANCE TRIPS OVER SEVERAL WEEKS WHERE COOLANT TEMPERATURE REMAINS BELOW 70?C (158?F) - WATER MAY ACCUMULATE IN THE MOTOR OIL. WATER THAT HAS ACCUMULATED IN THE MOTOR OIL WILL EVAPORATE AFTER THE ENGINE OIL TEMPERATURE EXCEEDS 70?C (158?F) AND COULD, WITHIN 15 TO 20 MINUTES OF DRIVING AT A CONSTANT SPEED WITH AN OUTSIDE TEMPERATURE BELOW -20?C (-4OF), CAUSE ICE TO FORM IN THE THROTTLE BODY.ACCORDING TO AUDI, THIS CONDITION OCCURS AT RELATIVELY LOW THROTTLE SETTINGS AND RESULTS IN THROTTLE STICKING AT POSITIONS THAT CAN BE CONTROLLED BY BRAKING.DURING TYPICAL VEHICLE USAGE (MIXTURE OF SHORT AND LONG DISTANCE DRIVING) THIS PHENOMENON IS NOT EXPECTED TO OCCUR.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.

THIS PE WAS OPENED BASED ON FOUR ODI COMPLAINTS THAT THE STEERING WHEEL OVERHEATS. VW HAS SHOWN THAT MOISTURE AND PRESPIRATION PERMEATE THE STEERING WHEEL COVER CAUSING THE HEATING ELEMENT TO CORRODE.THIS CORROSION MAY CAUSE A SMALL, LOCALIZED AREA OF THE STEERING WHEEL TO EXPERIENCE A BRIEF DURATION OF OVERHEATING.THERE ARE NO REPORTS OF THE STEERING WHEEL SUSTAINING COMBUSTION. THE INVESTIGATION HAS FOUND NO OCCURRENCES OF SEVERE BURNING AND NO CONSUMERS REQUIRED MEDICAL ATTENTION. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

Takata recall. The contact owns a 1998 Audi A6. The contact received notification of NHTSA campaign number: 20V056000 (Air Bags) however, the part to do the recall repair was not yet available. The vehicle was taken to the local dealer who stated the parts were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.

NHTSA ID

11428048

Incident

Jan 30, 2020

FUEL WAS FOUND LEAKING FROM THE ROLLOVER VALVE NIPPLE ON THE FUEL TANK. THIS NIPPLE HAS BEEN KNOWN TO CRACK WHEN THE METAL VENTILATION LINE LINE ADDS STRESS TO THE PLASTIC NIPPLE. GASOLINE WAS FOUND IN A PUDDLE ON THE FLOOR AT THE LEFT/ REAR OF THE CAR. AUDI HAS RECALLED AND REPAIRED THIS DEFECT ON LATER YEAR A6S BUT AUDI OF AMERICA, INC. REFUSED TO REPAIR THE 1998 A6. THE GAS TANK ON THE 98 A6 IS IDENTICAL TO THE GAS TANK ON THE RECALLED VEHICLES. THE NATIONAL HIGHWAY SAFETY ADMINISTRATION HAS ALREADY DETERMINED THAT THESE FUEL TANKS PRESENT A SERIOUS FIRE HAZARD AND PARTICIPATED IN A RECALL. THIS RECALL NEEDS TO BE EXPANDED TO INCLUDE ALL A6 VEHICLES WITH THE DEFECTIVE PLASTIC NIPPLE INCLUDING THE 1998 AUDI A6 IN QUESTION.

NHTSA ID

11355251

Incident

Aug 31, 2020

Mileage

224,580 mi

TL* THE CONTACT OWNS A 1998 AUDI A6. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE DASHBOARD WIRES HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE AND VIN WAS NOT AVAILABLE. *TR

NHTSA ID

10568879

Incident

Feb 26, 2014

TL* THE CONTACT OWNS A 1998 AUDI A6. WHILE TRAVELING 25 MPH, THE CONTACT NOTICED THAT THE FRONT END OF THE VEHICLE HAD SUDDENLY DROPPED TO THE GROUND. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE FRONT LOWER CONTROL ARM WAS REPLACED TWICE. THE FAILURE CONTINUED. THE FAILURE AND CURRENT MILEAGES WERE 150,000. UPDATED 5/7/12 *CN THE CONSUMER STATED ONE MONTH PRIOR, WHILE TURNING OFF A ROAD, THE VEHICLE DROPPED TO 25 MPH, THERE WAS LOSS OF BRAKES AND THE VEHICLE WAS HARD TO CONTROL. UPDATED 05/30/10

NHTSA ID

10451930

Incident

Mar 12, 2012

Mileage

150,000 mi

I AM EXPERIENCING AN ISSUE WITH MY VEHICLE THAT WAS RECALLED BY THE FACTORY AUDI AG BUT MY VEHICLE WAS NOT LISTED AS ONE OF THE RECALLED VEHICLE. I AM AFRAID OF GETTING STRANDED DUE TO AN IMPROPER FUEL READING. PLEASE ADDRESS THIS ACCORDINGLY, THANK YOU. *TR

NHTSA ID

10314095

Incident

Feb 7, 2010

Mileage

163,895 mi

DEAR DOT, I'VE A 1998 AUDI A6 QUATTRO. MY ABS SYSTEM SHOWS WARNING YELLOW ABS LIGHT AND RED FLASHING BRAKE LIGHT AT ALL TIME. I'VE TAKEN MY TWO SHOPS AND THEY BOTH INDICATED THAT THE ABS UNIT IS DEFECTIVE AND NEEDS REPLACEMENT. THEY TESTED ALL 4 WHEEL SENSORS ON THE CAR AND ALSO MAPPED OUT THE ELECTRICAL SYSTEM. THE CONCLUSION WAS A DEFECTIVE ABS UNIT. I'VE DONE SOME RESEARCH AND OTHER AUDI OWNER FROM 1998 - 2001 ALSO HAVE THE SAME ISSUES. IF THIS SYSTEM IS KNOWN TO BE DEFECTIVE, IT SHOULD BE RECALLED IN ALL FAIRNESS. I AM PRETTY HAPPY WITH THIS CAR, BUT THE ABS IS AN UNCOMFORTABLE EXPERIENCE. IT COST ABOUT $2000 TO REPLACE THE ABS UNIT AND AUDI DOES NOT WANT TO ADMIT THE PROBLEM. REFERENCES: HTTP://AUDI-VW-ABS-RECALL.BLOGSPOT.COM HTTP://WWW.ALLWORLDAUTO.COM/COMMENTS/AUDI_A4_AVANT_COMMENTS_AND_COMPLAINTS_65-34245-1.HTML

NHTSA ID

10291873

Incident

Nov 5, 2009

Mileage

120,000 mi

FIRE HAZARD DUE TO OIL LEAKING ONTO EXHAUST. *TR

NHTSA ID

10265462

Incident

Apr 15, 2009

I HAVE AN 1998 AUDI A6, 2.8L, V6, QUATTRO, AVANT WITH A 115000 MLS AND MY CARS'S REAR SEAT, SEAT BELT IN (THE MIDDLE PASSENGER "BELT SHAPE, ONE") SEAT STOP WORKING AND IT IS STUCK IN ITS OPEN POSITION ABOUT 15"-16" OUT. AFTER TALKING TO THE AUDI DEALER NEAR HOME THEY SAID, YEAH NOT WORKING BUT SORRY OUT OF WARRANTY, I ASKED IS THIS A SAFETY ISSUE FOR THIS CAR? THEY SAID NO! ITS NOT! I AM NOT SURE ABOUT THAT. IS THAT OK A SEAT BELT IN REAR SEAT HARDLY USED BY ME BREAK SO EASY?! I HAVE SEEN MANY PARENTS USE THIS SEAT BELT TO SECURE THERE CHILD'S CAR SEAT TO THE CAR'S SEAT? THANK YOU. *TR

NHTSA ID

10257419

Incident

Feb 15, 2008

Mileage

115 mi

This communication is issued to inform dealers of updated shipping regulations related to lithium ion batteries.

This communication is issued to remind dealers of the repair validation process for repair group 19. 2005-2019 A3, 1996-2019 A4, 2008-2019 A5, 1992-2019 A6, 2012-2019 A7, 1997-2019 A8, 2019 E-Tron, 2015-2019 Q3, 2010-2019 Q5, 2007-2019 Q7, 2019 Q8, 2000-2019 TT, 2008-2018 R8

This informational bulletin contains technical information for when there is condensation visible on the inside of the headlight, taillight, fog light, side marker light, front turn signal, daytime running lights, and/or third brake light lens.

This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward.

This informational bulletin contains all the the Audi Oil Quality Standards that should be used when doing an oil change.

Due to increasing requests for high voltage personal protective equipment (HVE PPE) for dealer technicians working with high voltage vehicles (Hybrid, Plugin Hybrid, Electric Vehicle), the Volkswagen Tools and Equipment Team has identified two US based suppliers to support dealers in USA and Canada.