2022 Jeep Grand Cherokee

On June 8, 2023, Fiat Chrysler Automobiles US, LLC (FCA) filed Safety Recall 23V-413 affecting certain 2022–2023 Jeep Grand Cherokee and2021–2023 Jeep Grand Cherokee L vehicles to address rear coil springs that may not have been properly installed during vehicle production. An improperly installed rear coil spring may detach while the vehicle is in motion, creating a road hazard that can increase the risk of a crash for following motorists and may result in injury to other road users. Since the filing of Recall 23V-413, the National Highway Traffic Safety Administration (NHTSA) has received twenty (20) unique consumer complaints alleging rear coil spring detachments occurring after the recall remedy was performed. These reports raise concerns regarding the effectiveness of the recall remedy and suggest the possibility of additional factors not addressed by the original recall campaign. Accordingly, the Office of Defects Investigation (ODI) is opening this Recall Query (RQ) to assess the adequacy of FCA’s remedy procedure under Recall 23V-413 and to evaluate the root cause(s) of post-remedy coil spring detachments. ODI will review complaint data, field reports, and FCA’s technical analysis to determine whether further action is warranted. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, visit NHTSA.gov.

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

Hybrid engine failure. Jeep vehicle is unsafe to drive as the electric engine doesn’t work due to overheating and charging error codes, which causes power to jump between electric and gas engine spontaneously causing speed control to be unpredictable and unsafe. There is also the question that there is a serious defect with the battery and unsafe to park this vehicle in a garage attached to a dwelling unit.

NHTSA ID

11774808

Incident

Oct 27, 2026

Summary of defect: The vehicle intermittently shifts into PARK while in motion or stopped in traffic, accompanied by a recurring "Service Stop/Start System" warning. This results in a sudden loss of drive power and creates a serious risk of a rear-end collision or crash. History: Shortly after purchase in March 2025, the vehicle began showing random dashboard warnings and infotainment/connectivity failures, which occurred daily. Approximately eight months after purchase, the "Service Stop/Start System" warning began recurring. In several instances this was accompanied by the transmission shifting into PARK while the vehicle was stopped at a red light. Within a few weeks, my wife was driving with our young children in the vehicle when it shifted into PARK in traffic, and she was nearly struck by another vehicle. The problem occurred several more times. Ain September 2026, I took the vehicle to Thomas Jeep [city, state] for repair. The dealership stated the issue was a software problem and returned the vehicle after 2–3 days. I paid for a rental vehicle out of pocket during that time. The Stop/Start warning returned immediately after I picked up the vehicle. A few weeks later, the vehicle again shifted into PARK, this time while driving, which was more severe than prior incidents. Current status: The defect has not been resolved. I transport my young children in this vehicle, including to daycare, and I consider it unsafe to drive. Request: I request that NHTSA open an investigation into this defect, review similar complaints for this make and model, and determine whether a recall is warranted.

NHTSA ID

11774580

Incident

Jan 15, 2026

Awaiting motor mounts. Causative water pump replacement. Loose feeling and creaking sound when operating the vehicle. Hard knocking sound when shifting gears to drive or reverse. I thought most of all of the sounds were normal because it is a Jeep. This has been for more than I realized.

NHTSA ID

11773638

Incident

Aug 19, 2026

My sun roof glass blew up while traveling on XXX in [XXX]. It sounded like a gunshot. I thought I blew a tire. Upon pulling over on the shoulder I discovered my Sun Roof had exploded. No other cars were on the road and I had not run over anything. If the shade had not been closed then I would have been covered with exploding shards of glass while traveling at 65 mph INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11773449

Incident

Oct 23, 2026

My sun roof glass blew up while traveling on XXX in [XXX]. It sounded like a gunshot. I thought I blew a tire. Upon pulling over on the shoulder I discovered my Sun Roof had exploded. No other cars were on the road and I had not run over anything. If the shade had not been closed then I would have been covered with exploding shards of glass while traveling at 65 mph INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11773448

Incident

Oct 23, 2026

[Incident Description & System Failure] On XXX, at approximately 30,340 miles, hybrid propulsion and charging system completely failed while the vehicle was in motion. The vehicle suffered a sudden "Loss of Motive Power" and stalled completely on a public road. The vehicle was towed immediately and is currently inspection upon request. [Safety Risks Experienced] The vehicle suffered a catastrophic power failure and stalled suddenly in the middle of a public road. This created an immediate hazard for a severe rear-end collision. Furthermore, according to the manufacturer's official Safety Recall 68C (NHTSA 25V-741), this specific battery pack poses an unmitigated vehicle fire risk, threatened by both traffic hazards and potential thermal runaway. [Dealer Confirmation & Inspection Status] The defect has been officially reproduced, confirmed, and documented by an authorized dealer. Following the sudden stall, the vehicle was towed to McPeeks CDJR of [XXX] on XXX (Repair Order #XXX). The service advisor and technicians confirmed the failure, noting the active check engine light and red battery light. The vehicle is currently under inspection and storage at the dealership, as the manufacturer's technicians have been unable to remedy this recurring. [Prior Warning Lamps, Messages & Symptoms] At the same time the engine stalled on XXX, the dashboard illuminated a red battery warning light and a check engine light, by a system message: "Service Charging System. The vehicle had a long history of chronic hybrid system symptoms and was previously brought to the dealer for multiple official safety recalls regarding the high-voltage battery (95B in Dec 2024, 73C in XXX, and 68C in XXX). The manufacturer issued a Warranty Extension Letter (Program XU1) for this defective battery pack. Despite all prior software flashes and recall "remedies" performed by the dealer, the system completely failed, proving the defect is incurable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11772311

Incident

Oct 4, 2026

This recall notice (26V-562) is the third time that Jeep has provided such a notice for precisely the same problem. On two previous occasions (24V-413 and 26V-051), the car was returned to the dealer and work was performed. Although Jeep appears to be following the guidelines for discovery and communication of a safety defect, the conclusion here is that the subject defect occurred in the design phase or in the assembly process at the factory, and, despite two recalls and the passage of at least four years, the problem has not been resolved on a reasonably timely basis. The traveling public remains at risk.

NHTSA ID

11771353

Incident

Oct 1, 2026

Our 2022 Jeep Grand Cherokee 4xe began making popping noises around the front wheel area while driving at approximately 45,000 miles. We paid a Jeep dealership to diagnose the problem. The dealership told us the control-arm bushings were worn and that the entire control-arm assembly needed replacement, with an estimated repair cost of approximately $5,500. We are concerned that a suspension component has failed prematurely at this mileage. The popping noises and diagnosed wear make us concerned about the vehicle’s safety. The dealership stated that the bumper-to-bumper warranty had expired and that the repair was not covered by the powertrain warranty. After the dealership’s diagnostic visit, a sway bar warning light also began appearing. We do not know whether this warning is related to the original problem, but it adds to our safety concerns. We subsequently took the vehicle to an independent licensed mechanic. According to that mechanic, Jeep informed him that the required parts were on backorder, creating an additional obstacle to completing the repair. While researching the symptoms, we found reports from other owners describing similar problems, along with potentially relevant service bulletins. We are providing those references for NHTSA’s review. We understand that these reports and the parts backorder do not, by themselves, establish a widespread defect. We cannot currently afford the quoted repair and are concerned about continuing to drive the vehicle. We request that NHTSA review this complaint for a possible safety-related suspension or sway bar defect and determine whether further investigation is warranted. Bulletin S2102000004 REV.D Bulletin 9100811 Rev 4 Bulletin 9100811 Bulletin S2102000004 REV.C Bulletin S2602000003 Bulletin S2521000004 REV.B

NHTSA ID

11771138

Incident

Jul 15, 2026

Auto Emergency Braking (AEB) Unavailable – Service Required Message In Cluster

Flash: Electronic Shift Module (ESM) Updates Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle must SYMPTOM: exhibit/set one or more of the following Diagnostic Trouble Codes (DTCs): ● U114C-00 - Lost Communication with PRNDL Display. ● P1C86-00 - PRNDL Display. Customers may comment on one or more of the following: ● "Service Shifter" message displayed in the Instrument Panel Cluster (IPC). ● PRNDL lights on the shifter are off. This bulletin involves reprogramming the ESM with the latest available software.

Compressor Assy High number of compressor replacements when complaint is noise and supplier analysis comes back as Trouble not found. Before replacing compressor due to noise complaint review the NEW Compressor noise section in the service library under 24 Heating and Air Conditioning- Diagnosis and Testing.

HEADLAMP

HEADLAMP

The Customer May Complain About a Popping Noise, Grinding Noise, or an Intermittent No Reverse or Forward Transmission Engagement. The Tech May Find Damaged and/or Worn Transmission Output Shaft Splines (850RE Transmission Only)